Abstract:A novel early gate dielectric AIGaN/GaN metal-insulator-semiconductor high-electron-mobility transistors (MIS-HEMTs) process is reported. With the highquality Si3N4 dielectric by low-pressure chemical vapor deposition and damage free, self-terminating passivation layer etching at the gate area, the MIS-HEMTs on 150-mm Si substrate demonstrate excellent output performance and good uniformity. The interface trap density between the gate insulator and the barrier layer is as low as 2 x 10(12) cm(-2).eV(-1) extracted by the conductance method. The MIS-HEMT fabricated on the wafer delivers an extremely small gate leakage current of 10(-9) mA/mm and a high I-on/I-off ratio of 10(11). The subthreshold swing (SS) is around 80 mV/dec, and the saturated output current density is 750 mA/mm. The dynamic on-resistance increases about 42% at a quiescent drain bias of 600 V. The V-th shift is -0.63 and -0.89 V at a high temperature of 200 degrees C and negative gate-bias stress of -25 V, respectively, indicating a comparable stability with the state-of-the-art MIS-HEMTs. An excellent threshold voltage and SS uniformity (1 - sigma/mu) with the value of 94.5% and 95.2% are achieved on the 150-mm wafer.

Single Step Electron-Beam Lithography Archiving Lift-off for T-gate in High Electron Mobility Transistor Fabrication

Stepping Electron-Beam Lithography for Y-gate in High Electron Mobility Transistors Fabrication

Spacer Side-wall Processed 0.15 Μm GaN HEMT for Ka-band Application

The Optimization and Fabrication of High Electron Mobility Transistors Integrated with Microstructure

Fabrication of 150-Nm Al 0.48 in 0.52 As/Ga 0.47 in 0.53 As Mhemts on GaAs Substrates

Fabrication of 80-Nm T-gate High Indium In0.7Ga0.3As/In0.6Ga0.4As Composite Channels Mhemt on GaAs Substrate with Simple Technological Process

Research on Self-Supporting T-shaped Gate Structure of GaN-based HEMT Devices

Mm-Wave Performance of 50nm T-Gate AlGaAs/InGaAs Pseudomorphic High Electron Mobility Transistors with Ft of 200 GHz

X-Ray Lithography Technology for the Fabrication of Deep-Submicron T-Shaped Gate

40nm T-gate Preparation Technology on GaAs Substrate

T-shaped Gate AlGaN/GaN HEMTs Fabricated by Femtosecond Laser Lithography Without Ablation

Fabrication of GaAs/AlGaAs high electron mobility transistors with 250 nm gates using conformal phase shift lithography

Fabrication of 150-nm T-Gate Metamorphic AlInAs/GaInAs HEMTs on GaAs Substrates by MOCVD

Fabrication of a resonant tunneling transistor with self-aligned gate

Fabrication of AlGaN/GaN Fin-Type HEMT Using a Novel T-Gate Process for Improved Radio-Frequency Performance

Nanofabrication of air-spaced field-plate gates with ultra-short footprint

Ion-Implanted TiN Metal Gate with Dual Band-Edge Work Function and Excellent Reliability for Advanced CMOS Device Applications

Fabrication of 30 nm T gates using SiN[sub x] as a supporting and definition layer

Fabrication of recessed-gate AlGaN/GaN MOSFETs using TMAH wet etching with Cu ion implantation

Fabrication of High-Uniformity and High-Reliability Si 3 N 4 /algan/gan MIS-HEMTs with Self-Terminating Dielectric Etching Process in a 150-Mm Si Foundry

Normally-Off p-GaN Gate High-Electron-Mobility Transistors with the Air-Bridge Source-Connection Fabricated Using the Direct Laser Writing Grayscale Photolithography Technology