Abstract:In the presence of a catalyst, the reforming of biomass tar to produce syngas, and its further use for chemical production, is a sustainable energy technology. However, to the best of our knowledge, the integration of tar reforming and downstream technology is still limited. In this work, an economical Ni/biochar catalyst was prepared and successfully applied for steam reforming of toluene (as a tar model compound) and syngas methanation. Under experimental conditions, the Ni/wheat straw (Ni/WS) char catalyst is active for syngas production and further for methane production in a wide temperature range. The physicochemical properties of the Ni/WS char catalyst were carefully characterized, and then the activity, stability, and deactivation of Ni/WS char in toluene reforming and methanation were elaborated. Ni/WS char possessed a smaller Ni crystallite size, and its lower activation energy resulted in higher toluene conversion (90.2%) and gas yield (261.4 mmol/gtoluene) compared with the commercial Ni/Al2O3 catalyst during toluene reforming. Furthermore, the produced syngas with an optimized H2/CO ratio of 3.01 was proved to be suitable for methane production over Ni/WS char, which therefore showed a high CO conversion (80.3%).The Supporting Information is available free of charge at https://pubs.acs.org/doi/10.1021/acssuschemeng.1c03497.Proximate and ultimate analyses of wheat straw; activity comparison and reaction conditions of different Ni-based catalysts in toluene reforming; activity comparison and reaction conditions of different Ni-based catalysts in CO methanation; weight changes of spent Ni/WSC-R and Ni/Al2O3-R at different temperatures and different S/C ratios; weight changes of spent Ni/WSC-R and Ni/Al2O3-R after 15 h TOS of SRT; TG curves of spent Ni/WSC-R and spent Ni/Al2O3-R (after 15 h TOS of SRT) and spent Ni/WSC-M and Ni/Al2O3-M (after 50 h TOS of methanation); weight changes of spent Ni/WSC-M and Ni/Al2O3-M at different temperatures and after 50 h TOS of methanation (PDF)This article has not yet been cited by other publications.

Reactivity and deactivation mechanisms of toluene reforming over waste peat char-supported Fe/Ni/Ca catalyst

Catalytic toluene steam reforming using Ni supported catalyst from pyrolytic peat

Catalytic Cracking and Catalyst Deactivation/regeneration Characteristics of Fe-loaded Biochar Catalysts for Tar Model Compound

Pyrolysis Char Derived from Waste Peat for Catalytic Reforming of Tar Model Compound

Synthesis and evaluation of pyrolysis waste peat char supported catalyst for steam reforming of toluene

Direct Conversion of Syngas Produced from Steam Reforming of Toluene into Methane over a Ni/Biochar Catalyst

Pyrolysis municipal sludge char supported Fe/Ni catalysts for catalytic reforming of tar model compound

Catalytic conversion of toluene as a biomass tar model compound using monolithic biochar-based catalysts decorated with carbon nanotubes and graphic carbon covered Co-Ni alloy nanoparticles

Enhanced H 2 -Rich Gas Production via Steam Reforming of Toluene over Ni-Based Hydrotalcite-Derived Catalysts at Low Temperature

Hydrogen production from catalytic steam reforming of toluene over trace of Fe and Mn doping Ni/Attapulgite

Preparation of High Catalytic Activity Biochar from Biomass Waste for Tar Conversion

Steam reforming of biomass tar model compound over two waste char-based Ni catalysts for syngas production

Arming wood carbon with carbon-coated mesoporous nickel-silica nanolayer as monolithic composite catalyst for steam reforming of toluene

Carbon-coated mesoporous silica-supported Ni nanocomposite catalyst for efficient hydrogen production via steam reforming of toluene

Promoting effects of Fe-Ni alloy on co-production of H2 and carbon nanotubes during steam reforming of biomass tar over Ni-Fe/α-Al2O3

Pyrolysis waste char supported metallic catalyst for syngas production during catalytic reforming of benzene

Pyrolysis of biomass Tar model compound with various Ni-based catalysts: Influence of promoters characteristics on hydrogen-rich gas formation

Catalytic Steam Reforming of Biomass Tar Model Compounds with Low Cost Catalysts: Effect of Operation Conditions

The effect of reaction condition on catalytic cracking of wheat straw pyrolysis volatiles over char-based Fe–Ni–Ca catalyst

Steam Reforming of Biomass Tar Model Compounds over Monolithic Catalysts

Low-Temperature Steam Reforming of Toluene and Biomass Tar over Biochar-Supported Ni Nanoparticles