Abstract:& nbsp;Considering electrical control of electrostatic precipitation, this paper discusses particle collection in terms of corona ionic wind, gas flow pattern and high-voltage power sources. Experiments and simulations were conducted with lab-scale and industrial electrostatic precipitators. In general, a larger electrostatic precipitator (ESP) index value leads to better ESP performance. To maintain the voltage, simulation results show that a three-phase power source could operate at a lower ripple factor of 0.8% and a shorter recovery time of 5 ms after spark-over than single-phase or high frequency transformer rectifiers. For an industrial ESP with several electric fields, optimal voltage or electric field strength drops from its inlet to outlet fields. It is normally around 3.3 kV cm(-1) with a large corona input power for the inlet field, and it drops to about 2.3 kV cm(-1) with a small input power to limit ionic wind induced reentrainment for the last field. For a typical Chinese 660 MW coal-fired boiler with a fourfield colder-side ESP, its outlet ash concentration and its PM10 and PM2.5 are usually around 15 mg m(-3), 12 mg m(-3) and 2 mg m(-3), respectively. According to particle image velocimetry observation and particle collection measurements, we found that the corona wind generated vortex can result in not only enhancement of collection but also particle reentrainment and/or the so-called 'bypass flow'. An optimum electric field inside the ESP exists to save energy and collect particles. For present ESPs, a higher electric field (>3.5 kV cm(-1)) generates strong electrohydrodynamic flow, which consequently undermines the collection due to turbulent flow. Advanced industrial automatic voltage controllers for three-phase transformer rectifier and double-wire ESPs have been developed according to those experimental results for both reducing emission and corona energy consumption.

Performance Comparison Between Micro and Electro Micro Cyclone

Performance Evaluation of a New Micro Gas Cyclone Using Simulation and Experimental Studies to Capture Indoor Fine Particles

Micro Gas Cyclone Design and Performance Evaluation to Collect Dust Particles

Introduction and Simulation of a Small Electro Cyclone for Collecting Indoor Pollen Particles

Characterization of Electrohydrodynamic Flow in a Plate-Plate Electrostatic Precipitator with a Wire-Cylinder Pre-Charger by Data-Driven Vortex and Residence Time Analysis

Electrical Control of Electrostatic Precipitation

Analytical Method for Particle Collection in a High-temperature Wire-cylinder Electrostatic Precipitator

Electrode Configurations Inside an Electrostatic Precipitator and Their Impact on Collection Efficiency and Flow Pattern

Cfd-Dem Investigation of Particle Elutriation with Electrostatic Effects in Gas-Solid Fluidized Beds

Measurements of Flow Field in Wire-plate Electrostatic Precipitator During Positive or Negative Corona Discharge Using PIV Method

Electrode Geometry Optimization in Wire-Plate Electrostatic Precipitator and Its Impact on Collection Efficiency

Performance and techno-economic evaluation of a high-efficiency electrospray cyclone

Performance experiments and pressure drop prediction modelling of an energy-saving cyclone separator

3D numerical simulation of particles collection in a high-temperature wire-cylinder electrostatic precipitator

Experimental study on the separation performance of an enhanced cyclone with shunt device

Current Density and Efficiency of a Novel Lab ESP for Fine Particles Collection

The Effect of Inlet Velocity, Gas Temperature and Particle Size on the Performance of Double Cyclone Separator

CFD Simulation of an Industrial Dust Cyclone Separator: A Comparison with Empirical Models: The Influence of the Inlet Velocity and the Particle Size on Performance Factors in Situation of High Concentration of Particles

Experimental study on a new type of cyclone separator for fine particles

Performance evaluation of cyclone separators with elliptical cross-section using large-eddy simulation

Experimental study on the gas-solid two-phase flow in a square cyclone separator with downward gas exit by particle dynamic analyzer