Abstract:The gas phase flow field inside a cyclone separator is crucial to the particle separation process. Previous studies have paid attention to the steady-state characteristics of the gas phase flow field, while research on its dynamic characteristics remains insufficient. Meanwhile, cyclone separators often adopt different structural forms according to the process requirements, the evolution laws of the dynamic characteristics flow field within them are still not well understood. Therefore, in this study, a hot-wire anemometer (HWA) was employed to measure the instantaneous tangential velocity of the gas phase flow fields within different structural cyclone separators (cylinder type, cylinder–cone (no hopper), and cylinder–cone (with hopper)). Comparative analyses and discussions were conducted regarding the dynamic characteristic distribution rules of the flow field in the time domain and the frequency domain. The results revealed that the dimensionless tangential velocity distributions of different types of cyclone separators all conformed to the Rankine vortex structure. The instantaneous tangential velocity fluctuated with low frequency and high amplitude, and the low-frequency velocity fluctuation exhibited a transfer behavior along the radial direction. Compared with the cylinder–cone-type cyclone separator, the tangential velocity in the cylinder-type cyclone separator fluctuated more greatly, and its quasi-periodic behavior was also more obvious. The time-averaged tangential velocity, the tangential velocity fluctuation intensity (Sd), and the dominant fluctuation frequency all had obvious attenuation along the axial direction in the cylinder-type cyclone separator, while the above-mentioned parameters had no attenuation along the axial direction in cylinder–cone-type cyclone separators. Additionally, the backflow from the hopper of the cylinder–cone-type cyclone separator (with hopper) led to an increase in the instantaneous tangential velocity fluctuation intensity of the local flow field near the dust outlet, as well as the occurrence of the "double dominant frequencies" phenomenon.

Experimental study on the gas-solid two-phase flow in a square cyclone separator with downward gas exit by particle dynamic analyzer

AN EXPERIMENTAL STUDY ON THE GAS-SOLID TWO-PHASE FLOW IN A SQUARE CYCLONE SEPARATOR WITH DOWNWARD GAS EXIT BY 3D-PDA

Micro Gas Cyclone Design and Performance Evaluation to Collect Dust Particles

Numerical Simulation of Three Dimensional Gas-Particle Flow in a Spiral Cyclone

Experimental Study and Numerical Simulation of the Characteristics of a Percussive Gas–solid Separator

Performance Evaluation of a New Micro Gas Cyclone Using Simulation and Experimental Studies to Capture Indoor Fine Particles

Experimental Study on the Particle Distribution in a Square Cyclone Separator

Numerical Simulating the Gas-solid Flow in Square Cyclone With a Curved Inlet

Study on Separation Performance of Tri-Cone Water Medium Cyclone Based on CFD

LES-DEM Investigation of the Gas-Solid Flow Characteristics in a Cyclone Separator

A study on gas flow in spiral inlet cyclone separator

Comparative Analyses of Dynamic Characteristics of Gas Phase Flow Field Within Different Structural Cyclone Separators

Effects of the inlet particle spatial distribution on the performance of a gas-solid cyclone separator

Numerical Simulation Of Gas-Solids Flow And Parametrical Studies In A Horizontal Square Cyclone

Numerical Study of Gas-Solid Flow in a Square Cyclone Separator with Different Vortex Finders

Experimental investigation on separation characteristics of axial cyclone separator

Experimental Study on the Three-Dimensional Two-Phase Flow Field in a Hydrocyclone

Investigation of Velocity of Square Cyclone with Accelerating Inlet

EXperimetal Study on the Diffusion Square Cyclone Seoarator

Numerical Simulation of Two-Phase Flow Field in Horizontal Square Cyclone

Numerical simulation study of particle self-rotation velocity in cyclone separator