Abstract:Abstract Recently, flat panel display technologies are based on amorphous silicon (a-Si), polycrystalline silicon (poly-Si) or amorphous oxide semiconductor (AOS) thin film transistors (TFTs) technology. In order to reach higher performance for ultra-high resolution display applications, the material selection for the channel layer is vital. AOS TFTs drawn lots of attention because of its advantages such as low leakage current, high driving current and high uniformity [1,3]. In this work, we presented a novel amorphous oxide semiconductor (AOS) material of gallium-free a-InWZnO thin film transistors (IWZO TFTs) which is very promising to be applied for ultra-high resolution display technology. Experiment In this work, we demonstrated the structure of a-IWZO TFTs processes. Figure 1 shows the schematic of the TFT cross-section. After growing a 550 nm thermal oxide layer as buffer layer, a 25-nm-thick of molybdenum was deposited by DC-sputter as the bottom gate electrode. A 10-nm-HfO 2 was deposited by plasma-enhanced atomic layer deposition (PEALD) system as high-κ gate dielectric (GI). Then, post deposition annealing (PDA) was carried out to enhance the quality of the insulator layer. Next, an ultra-thin body a-IWZO was deposited by RF-sputter as channel layer. Finally, source and drain were defined by lift-off process and the gate contact via was etched by dry etching to finish the device fabrication. Result and Discussion Figure 1(b) shows the negative gate bias stress (NGBS) transfer curve (I D -V G ) of a-IWZO TFTs with passivation layer. The experimental results have shown that passivation layer could keep the back channel of IWZO channel from exposing to oxygen and hydrogen from the atmosphere. Without the passivation layer, the back channel would contact moisture leading the diffused hydrogen atoms to fill oxygen vacancy sites and de-trap free carriers, causing the V TH shifts negatively. The ultra-thin a-IWZO TFTs with passivation layer exhibited a low subthreshold swing (S.S.) of 89.7 mV/dec, high on/off current ratio (I ON /I OFF ) of 2.1×10 7 and small threshold voltage shift (ΔV th ) of -0.097 V during NGBS of -2MV/cm with 2000s. To sum up, the passivation layer could enhance the a-IWZO TFTs reliability. Reference [1] Kamiya, H. Hosono, NPG Asia Mater ., vol. 2, pp. 15, 2010. [2] Nomura, H. Ohta, A. Takagi, T. Kamiya, M. Hirano, and H. Hosono, nature, vol. 432, no. 7016, pp. 488-492, 2004. [3] Y. Kuo, C. M. Chang, I. H. Liu, and P. T. Liu, Scientific reports, vol. 9, no. 1, pp. 1-7, 2019. Figure 1

Design Of Highly Stable Tungsten-Doped Izo Thin-Film Transistors With Enhanced Performance

Improvement of Electrical Characteristics and Stability in Low-Voltage Indium Oxide Thin-Film Transistors by Using Tungsten Doping

Highly Stable Atomic Layer Deposited Zinc Oxide Thin-Film Transistors Incorporating Triple O 2 Annealing

Improvement of the Long-Term Stability of ZnSnO Thin Film Transistors by Tungsten Incorporation Using a Solution-Process Method

Influence of Tungsten Doping on the Performance of Indium–Zinc–Oxide Thin-Film Transistors

Solution-processed High Stability Top-Gate W and F Co-Doped ZnSnO Thin Film Transistors

High Reliability Tungsten-Doped Indium Zinc Oxide Thin Film Transistors for Display Applications

Enhancing the Stability and Mobility of TFTs via Indium-Tungsten Oxide and Zinc Oxide Engineered Heterojunction Channels Annealed in Oxygen Ambient

Study of Highly Stable Nitrogen-Doped a-InGaSnO Thin-Film Transistors

Performance Enhancement of Indium Zinc Oxide Thin-Film Transistors Through Process Optimizations

Solution-processed Coplanar Top-Gate ZnInSnO Thin Film Transistors and Bias Stability

Enhanced electrical performance and stability of solution-processed oxide semiconductor thin-film transistors via an incorporation of deionized water oxidizer

Effect of Indium Doping on Bias Stability in Dual-Target Co-Sputtering InZnSnO Thin-Film Transistors

Titanium doped Zinc-oxide based Thin Film Transistors: Optimization of the source/drain materials

Enhanced Stability of Solution-Processed Indium–Zinc–Tin–Oxide Transistors by Tantalum Cation Doping

Performance Improvement of Amorphous Thin-Film Transistors with Solution-Processed InZnO/InMgZnO Bilayer Channels

Scalability and Stability Enhancement in Self-Aligned Top-Gate Indium- Zinc-Oxide TFTs with Al Reacted Source/Drain

Water-Processed Ultrathin Crystalline Indium–Boron–Oxide Channel for High-Performance Thin-Film Transistor Applications

Improved Performance and Bias Stability of Al2O3/IZO Thin-Film Transistors with Vertical Diffusion

High-Performance Amorphous InGaZnO Thin-Film Transistor Gated by HfAlOₓ Dielectric with Ultralow Subthreshold Swing

Nitrogen-Doped Amorphous InZnSnO Thin Film Transistors with a Tandem Structure for High-Mobility and Reliable Operations