Abstract:In this paper, the main results of an experimental study on SO2 absorption in a bench-scale θ-ring packed tower using 0.3 mol·L−1 ethylenediamine-phosphoric acid solution was reported, and the effects of main technological parameters on the desulfurization efficiency were investigated. To uncover the mechanism behind the experimental observation, a one-dimensional model incorporated with equations of vapor-liquid equilibrium, heat, and mass transfer for simulating chemical absorption of SO2 with packed tower was also presented. Furthermore, the parameter distributions associated with heat and mass transfer characteristics along the absorber were also investigated. The results indicated that the relative errors of desulfurization efficiency between predicted and experimental values are less than 18.5% under different conditions and the model had depicted the tendency quite well. In addition, the desulfurization efficiency has positive correlation with increasing liquid-gas ratio, packing height, and ethylenediamine concentration, and declines with the increasing of inlet SO2 concentration, S(IV) concentration of lean amine, and operating temperature, respectively. Insights are given on the contribution of liquid chemistry reaction and interphase mass transfer on effective utilization of packing layer. Especially, enhancement factor and mass-transfer driving force along the absorber impact directly the SO2 absorption efficiency. Furthermore, the temperature rise has multiple effects on SO2 flux distribution, as mainly reflected in gradual accumulation of SO2(free) and decreasing of SO2 solubility in amine solution. This model can provide engineering guidance to design a packed tower as well as desulfurization process optimization.

Experimental Research on Flue Gas Desulfurization by Ethylenediamine/Phosphoric Acid Solution

Experimental study of new desulfurizer for removal of H2S

Studies on flue gas desulfurization by chemical absorption using an ethylenediamine-phosphoric acid solution

Study and optimization of catalytic oxidation technology in spent caustic desulfurization

Modeling and experimental studies on chemical absorption of sulphur dioxide with ethylenediamine-phosphoric acid solution in a θ-ring packed tower for purification of flue gas

Streamer Plasma Induced Ammonia Flue Gas Desulfurization

A Semi-Wet Technological Process for Flue Gas Desulfurization by Corona Discharges at an Industrial Scale

Chemical Absorption of SO2 by Using Ethylene Diamine/Phosphoric Acid Solution

Experimental study on factors affecting the ammonia-based WFGD process

Experimental Study of Wet Flue Gas Desulphurization of Impinge Liquid Column Tower

Investigation on Removal Effects and Condensation Characteristics of Condensable Particulate Matter: Field Test and Experimental Study.

Influence of Multi-Components Solutions Additives on The Characteristic of Spray Draying Desulfurization

Experimental study on SO2 absorption rate enhanced by additive in limestone-gypsum WFGD process

Study on NOx Absorption Into(NH4)2SO3 Solution in the Process of Ammonia-based Wet Flue Gas Desulfurization

Experimental Study of Desulfurization Process with Limestone Slurry Enhanced by Hexanedioic Acid

Experimental Study on Removal Characteristics of SO3 by Wet Flue Gas Desulfurization Absorber

Gas–liquid Absorption Reaction Between (NH4)2SO3 Solution and SO2 for Ammonia-Based Wet Flue Gas Desulfurization

STUDY ON DESULFURIZATION CHARACTERISTIC IN CaO ACTIVATION REACTOR OF LIMESTONE INJECTION FGD SYSTEM --EXPERIMENTAL RESULTS AND DISCUSSION

Experimental Study on the Preparation of Desulfurizer for Low Temperature Dry Desulfurization by Digesting CaO in Urea Solution

Continuous SO2 absorption and desorption in regenerable flue gas desulfurization with ethylenediamine-phosphoric acid solution: A rate-based dynamic modeling

Experimental study on the treatment of desulfurization wastewater from coal-fired power plant by spray evaporation