Abstract:Direct sulfidation using a high concentration of H2S (HC-H2S) has shown potential for heavy metals removal in various acidic effluents. However, the lack of a smooth method for producing HC-H2S is a critical challenge. Herein, a novel short-process hydrolysis method was developed for the on-site production of HC-H2S. Near-perfect 100% efficiency and selectivity were obtained via CS2 hydrolysis over the ZrO2-based catalyst. Meanwhile, no apparent residual sulfur/sulfate poisoning was detected, which guaranteed long-term operation. The coexistence of CO2 in the products had a negligible effect on the complete hydrolysis of CS2. H2S production followed a sequential hydrolysis pathway, with the reactions for CS2 adsorption and dissociation being the rate-determining steps. The energy balance indicated that HC-H2S production was a mildly exothermic reaction, and the heat energy could be maintained at self-balance with approximately 80% heat recovery. The batch sulfidation efficiencies for As(III), Hg(II), Pb(II), and Cd(II) removal were over 99.9%, following the solubilities (Ksp) of the corresponding metal sulfides. CO2 in the mixed gas produced by CS2 hydrolysis did not affect heavy metals sulfidation due to the presence of abundant H+. Finally, a pilot-scale experiment successfully demonstrated the practical effects. Therefore, this novel on-site HC-H2S production method adequately achieved heavy metals removal requirements in acidic effluents.

Experimental study of new desulfurizer for removal of H2S

Study and optimization of catalytic oxidation technology in spent caustic desulfurization

Electrochemical Removal of Hydrogen Sulfide and Recovery of the Deposited Sulfur on the Anode from Wastewater

Performance and Optimization of Integrated Biogas Bio-desulfurization Reactor

Study on selective hydrogen sulfide removal over carbon dioxide by catalytic oxidative absorption method with chelated iron as the catalyst

Sb-Fe bimetallic non-aqueous phase desulfurizer for efficient absorption of hydrogen sulfide: A combined experimental and DFT study

Application and Research of High Molecular Carboxylates in Desulphurization System of Thermal Power Plant

Experimental Research on Flue Gas Desulfurization by Ethylenediamine/Phosphoric Acid Solution

Enhanced Desulfurization by Tannin Extract Absorption Assisted by Binuclear Sulfonated Phthalocyanine Cobalt Polymer: Performance and Mechanism

Studies on the Combined Technology of Chemical Precipitation and Electrocatalytic Oxidation for the Pretreatment of Desulfurization Wastewater

Removal of Hydrogen Sulfide by Hydroxyl-Ferric Oxide in a Slurry Reactor at Low Temperature

Desulfurization of gases with a buffering solution of basic ironic salts

Effects of Ferric Salts on Sludge Anaerobic Digestion and Desulphurization

Study of intrinsic sulfidation behavior of Fe2O3 for high temperature H2S removal

Experimental investigation of sulfite oxidation enhancement in a micro-pore aeration system

A Study of High Temperature Desulfurization and Regeneration Using Iron-Calcium Oxides in a Fixed-Bed Reactor

A Study on the Desulfurization Performance of Solvent UDS for Purifying High Sour Natural Gas

Experimental Study on the Preparation of Desulfurizer for Low Temperature Dry Desulfurization by Digesting CaO in Urea Solution

Experimental study on factors affecting the ammonia-based WFGD process

Production of H2S with a Novel Short-Process for the Removal of Heavy Metals in Acidic Effluents from Smelting Flue-Gas Scrubbing Systems

Two-step hot coal gas desulphurization process integrated with direct production of elemental sulfur using iron-based sorbents: A preliminary study