Abstract:This paper reports a study on the simultaneous removal characteristics of SO3 in a wet flue gas desulfurization (WFGD) system. The impacts of the operating parameters, including liquid-to-gas (L/G) ratio, inlet SO3 concentration, flue gas temperature, superficial velocity, and slurry temperature, on the SO3 removal efficiency and SO3 aerosol characteristic were studied. Results showed that the overall SO3 removal efficiency varied from 20% to 55% under the experimental conditions. For the SO3 aerosol, particles measuring <0.1 mu m and >0.5 mu m had a higher removal efficiency, whereas particles measuring 0.1-0.5 pm were relatively difficult to remove in the WFGD system. Increases in L/G ratio and SO3 concentration exerted positive effects on the SO3 aerosol capture, whereas superficial velocity, flue gas temperature, and slurry temperature had negative effects. After installing a sieve plate, the SO3 removal efficiency increased from 49.88% and 53.46% to 51.77% and 58.05%, respectively, under two typical conditions. A multilayer perceptron artificial neural network model was applied to evaluate the relative importance of each parameter in SO3 removal performance. Results showed that inlet flue gas temperature, inlet SO3 concentration, and slurry temperature had a relatively strong impact on SO3 removal performance.

Experimental study on factors affecting the ammonia-based WFGD process

Experimental study of new desulfurizer for removal of H2S

Streamer Plasma Induced Ammonia Flue Gas Desulfurization

Analysis and Optimization of Chemical Processing Parameters for Wet Flue Gas Desulphurization System

Research on Properties of Ammonia-Bisulfite WFGD in Stone-Coal Fired Power Plant

Experimental Study of Wet Flue Gas Desulphurization of Impinge Liquid Column Tower

Experimental study on factors affecting efficiency of flue gas desulfurization by spray drying wet (semi-dry) process

STUDY ON DESULFURIZATION CHARACTERISTIC IN CaO ACTIVATION REACTOR OF LIMESTONE INJECTION FGD SYSTEM --EXPERIMENTAL RESULTS AND DISCUSSION

Simulation and optimization of ammonia-based flue gas desulfurization process

Experimental Study of Limestone/Gypsum-based Wet Process Flue Gas Desulfuration

Experimental Study on Removal Characteristics of SO3 by Wet Flue Gas Desulfurization Absorber

Experimental study on SO2 absorption rate enhanced by additive in limestone-gypsum WFGD process

Study on the Effect of Wet Flue Gas Desulphurization (WFGD) Technology on Flue Gas Particle Emission from Power Plants

Study on Parameter Optimization of Desulfurized Wet Flue Gas in Spray Condensation Process

Experimental Study of Operating Parameters Upon Water Consumption in Wet Desulphurization System

Factors Influencing Desulfurization Efficiency of Wet Flue Gas Desulfurization System

Application and experimental investigation of compound additive enhanced wet flue gas desulfurization process

Experimental and Theoretical Studies on Desulfurization Efficiency of Dual-alkali FGD System in a RST Scrubber

Study on Spray Condensation Performance of Desulfurization Wet Flue Gas

Factors influencing desulphurization efficiency of wet flue gas desulphurization system

Effect of Operational Parameters of Wet Flue Gas Desulfurization on Water Consumption