Abstract:Absorptive separation for resource utilization by selective SO2 removal from flue gas is a potential method applicable in practice. A flue gas desulfurization process for SO2 utilization by selective absorption in a lab-scale absorption tower at atmospheric pressure using N-formylmorpholine (NFM) as the absorbent is developed to capture and concentrate the SO2 from flue gas, in which the CO2 content is several orders higher than that of SO2. The investigation of the effects of different operating conditions on the SO2 removal efficiency shows that the SO2 removal efficiency can be obviously enhanced by increasing NFM concentration, or decreasing the absorption temperature, the superficial gas velocity, the gas-liquid ratio, or the SO2 concentration in absorption solution. Under the optimum operating conditions (covering a temperature of 40 degrees C, a superficial gas velocity of <0.0165 m/s, a gas-liquid ratio of 200-250, a SO2 concentration in lean NFM solution of 0-10 mg/L, and a NFM concentration of 3 mol/L), the SO2 removal rate reaches over 99.5% while the absorption of CO2 is negligible. Similarly, the SO2 removal rate is as high as 99.5% obtained in consecutive absorption-desorption cycles. Desorption experiment results indicate that the absorption of sulfur dioxide is completely reversible and the release of SO(2 )from NFM is very easy and rapid at 104 degrees C. The absorption simulation result for desulfurization of flue gas vented from the industrial catalytic cracking regenerator shows that 98.0% of SO2 can be absorbed in the absorber and most of them are released in the desorber. The experimental and simulated results show that the desulfurization ability and regenerability of NFM solution is encouraging for the development of FGD process to capture the SO2 from flue gas.

Gas–liquid Absorption Reaction Between (NH4)2SO3 Solution and SO2 for Ammonia-Based Wet Flue Gas Desulfurization

Study on NOx Absorption Into(NH4)2SO3 Solution in the Process of Ammonia-based Wet Flue Gas Desulfurization

Study on NO_x Absorption Into(NH_4)_2SO_3 Solution in the Process of Ammonia-based Wet Flue Gas Desulfurization

Kinetics of NOx absorption into (NH4) 2SO3 solution in an ammonia-based wet flue gas desulfurization process

Streamer Plasma Induced Ammonia Flue Gas Desulfurization

Chemical Absorption of SO2 by Using Ethylene Diamine/Phosphoric Acid Solution

Simultaneous wet absorption of SO2 and NOX with mixed Na2SO3 and (NH4)2SO3: Effects of mass concentration ratio and pH

Experimental Study on Removal Characteristics of SO3 by Wet Flue Gas Desulfurization Absorber

Absorption kinetics of SO2/NO in KMnO4/NaOH solutions

Studies on flue gas desulfurization by chemical absorption using an ethylenediamine-phosphoric acid solution

Hydrolysis of Urea for Ammonia-Based Wet Flue Gas Desulfurization

Novel Process of Removal of Sulfur Dioxide by Aqueous Ammonia–Fulvic Acid Solution with Ammonia Escape Inhibition

Effect of Additive Agents on the Simultaneous Absorption of No2 and So2 in the Calcium Sulfite Slurry

Effective Absorption Mechanism of SO2 and NO2 in the Flue Gas by Ammonium-Bromide-Based Deep Eutectic Solvents

Absorption Kinetics of SO_2/NO in KMnO_4/NaOH Solutions

Simultaneous Absorption of SO2 and CO2 from Flue Gas Using Aqueous Ammonia

CHARACTERISTICS OF SULFURDIOXIDE ABSORPFION IN MULTI-COMPONENT SUSPENSIONS

Effect of gas-liquid phase compositions on NO2 and NO absorption into ammonium-sulfite and bisulfite solutions

Kinetics of gas-liquid reaction between NO and Co(NH3)6(2+).

Study on Flue Gas Desulfurization Process with Selective SO2 Removal by N-formylmorpholine

Simultaneous Removal of SO2 and NO2 on Α-Al2o3 Absorbents Loaded with Sodium Humate and Ammonia Water