Abstract:Wet scrubbing is an effective nitric oxide (NO) emission control technology for marine diesel engines. Sodium persulfate (Na2S2O8) can efficiently oxidize NO and promote the absorption of NO. The activation of Na2S2O8 could enhance the mass transfer process of NO. However, the reaction kinetic mechanism of this method remains unclear, which was investigated through a bubble column reactor in this paper. The effects of several parameters on the NO absorption rate were tested with the gas flow rate of 0.8 L/min and the absorber volume of 1.0 L at 1 atm. It was found that the NO absorption rate was promoted gradually with the increase of the Na2S2O8 concentration (0.01–0.15 mol/L), NO inlet concentration (400–1200 ppm), and temperature (303–343 K). The NO absorption rate increased by 137.00% and then decreased by 1.05% as the pH value increased from 7 to 10 and then rose to 12, while the pH in the acidic solution had little effect on the nitric oxide absorption rate. In addition, during the oxidation of NO, the activation of Na2S2O8 could generate sulfate radicals ( SO 4 · − ) and hydroxyl radicals (OH·), which would significantly increase the NO absorption rate due to the strong oxidizing nature of free radicals. Simulation results showed that the absorption process is a pseudo-0.6-order for NO and a pseudo-0.15-order for Na2S2O8. The mass transfer process, especially the gas phase mass transfer, was the main rate-determining step for the NO absorption and the location of the reaction was the liquid film. Moreover, the established NO absorption model is in good agreement with the experimental results. It illustrated that the Na2S2O8/seawater system shows great application potential in marine exhaust gas purification.

Absorption of NO2 into Na2S Solution in a Stirred Tank Reactor

Kinetic Studies on NO2Absorption into Ammonium Sulfite Solutions

Kinetics of NOx absorption into (NH4) 2SO3 solution in an ammonia-based wet flue gas desulfurization process

Kinetics of Nitric Oxide Absorption from Flue Gas Using an Advanced Oxidation Process with Sodium Persulfate Solution

Effect of gas-liquid phase compositions on NO2 and NO absorption into ammonium-sulfite and bisulfite solutions

Absorption of NO into NaClO3/NaOH Solutions in a Stirred Tank Reactor

Study on NO_x Absorption Into(NH_4)_2SO_3 Solution in the Process of Ammonia-based Wet Flue Gas Desulfurization

Absorption of NOx from flue gas with alkaline aqueous solution combined with gas-phase oxidation of NO using ozone

Study on NOx Absorption Into(NH4)2SO3 Solution in the Process of Ammonia-based Wet Flue Gas Desulfurization

Kinetics of NO Absorption in Aqueous Iron(II) Bis(2,3-dimercapto-1-propanesulfonate) Solutions Using a Stirred Reactor

Experiment on Simultaneous Absorption of NO and SO2 from Sintering Flue Gas by Oxidizing Agents of KMnO4/NaClO

Study On The Absorption Rate Of No With Aqueous Ferrous Cysteine Solutions In A Double-Stirred Cell

Numerical Simulation of No2 Absorption Using Sodium Sulfite in A Spray Tower

Experimental Study on the Simultaneous Removal of SO_2 and NO by High Efficiency Liquid Absorbent

Kinetics of No Absorption in Aqueous Iron (ii)thiochelate Solutions

Absorption of NO in Aqueous NaClO2/Na2CO3 Solutions

Absorption kinetics of SO2/NO in KMnO4/NaOH solutions

Absorption Kinetics of SO_2/NO in KMnO_4/NaOH Solutions

Studies on the absorption of nitric oxide by ferrous cysteine solution

Simultaneous wet absorption of SO2 and NOX with mixed Na2SO3 and (NH4)2SO3: Effects of mass concentration ratio and pH

Gas–liquid Absorption Reaction Between (NH4)2SO3 Solution and SO2 for Ammonia-Based Wet Flue Gas Desulfurization