Abstract:Cordierite glass-ceramics usually begin to crystallize from the surface. As an efficient nucleating agent, TiO2 can promote the rapid transformation of glass to bulk crystallization, but it is easy to cause the increase of dielectric constant and light absorption. High crystallinity cordierite glass-ceramics were prepared by optimizing the heat treatment process without or with different nucleating agents in stoichiometric cordierite glasses. The results show that the crystallization mechanisms of glasses without and with ZrO2+P2O5 as nucleation agents are controlled by surface crystallization. While, the glass with TiO2+ZrO2+P2O5 as nucleation agents have the tendency to be bulk crystallization. The studied glasses are crystallized from surface and have different crystallization orientations with the inner glass. The thickness of crystalline layer increased with the increasing of heating temperatures, but the "surface-center" crystallization process cannot complete by further increasing heating temperatures because of softening deformation of glasses. At 1020 ℃, the glasses complete the "surface-center" crystallization for long durations. The glasses without nucleation agents and with ZrO2+P2O5 require 10 h, but the glass with TiO2+ZrO2+P2O5 complete for 5 h. Although all the three glasses complete the "surface-center" crystallization, the glasses with nucleation agents show the higher crystallinity upon the same heat treatments. Finally, glass-ceramics with excellent performance were obtained, for example, the Z1# glass-ceramic have the high microhardness ∼7.4 GPa, low thermal expansion coefficient ∼1.4☓10−6 ℃-1 at 20–300 ℃, and relatively high thermal conductivity ∼2.4 W/mK. It also exhibits low dielectric constant and loss, which was ∼4.5 and ∼1.2☓10-3 at 1 MHz, ∼ 4.9 and 2.3☓10-3 at 10.5 GHz..

Crystallization in Pb-Zr-Ti-Si-O Gel Glass

The post crystallization process of lead zirconate titanate films and effects on dielectric properties

Crystallization, phase evolution and ferroelectric properties of sol-gel-synthesized Ba(Ti0.8Zr0.2)O3-x(Ba 0.7Ca0.3)TiO3 thin films

Preparation and characterization of ZnO-B2O3-SO2 by sol-gel method

Sol-Gel Process and Properties of Textured Pb(Zr, Ti)O-3 Films on Silicon Wafers

Preparation and Characterization of ZnO-B2O3-SiO2 by Sol-Gel Method

Preparation of Zirconia Powders by Sol-gel Process

LOW-TEMPERATURE SYNTHESIS OF ZRO2-TIO2-SIO2 GLASSES FROM ZR(NO3)4.5H2O, SI(OC2H5)4 AND TI(OC4H9)4 BY THE SOL-GEL METHOD

Preparation on the [(Pb,La) (Zr,Ti)O3] ferroelectric thin films by using the Sol-Gel processing

Exploration of single-crystal like electrospun Pb(Zr_(0.52)Ti_(0.48))O_3 nanofibers synthesis via electrospinning

Crystallization, structure, and properties of TiO2-ZrO2 co-doped MgO-B2O3-Al2O3-SiO2 glass-ceramics

Synthesis and characterization of nanocrystalline PZT powders by a simple sol-gel method

Structural characterization and optical properties of Sol-gel-derived polycrystalline Pb(Zr 0.35 Ti 0.65 )O 3 thin films

Refractive Index Adjustment of SiO2 Gel Glass with Zirconium Oxychloride

Microstructure and Crystallization Behavior of Glasses in the ZrO2-ZnO-Al2O3-SiO2 System

Crystallization and mechanical properties of a barium titanosilicate glass

Crystallization of piezoceramic films on glass via flash lamp annealing

Preparation and characterization of Sol-Gel derived PZT bulk ceramics and thin films

Fabrication of SiO2 and SiO2-ZrO2 gel glasses by non-hydrolytic sol-gel process

Crystallization mechanisms of cordierite glass-ceramics with “surface-center” crystallization behavior