Abstract:The photovoltaic properties of the polycrystalline silicon depend on the crystallinity and the purity of the material. The thermal plasma process gives us an alternative method of silicon preparation since it is possible to produce an ultrahigh purity with simultaneously a passivation of crystalline defects and active impurities. We demonstrate the efficiency of the plasma purification process and particularly the influence of the atomic hydrogen in an argon thermal plasma on the photovoltaic properties of silicon. The results of the diffusion lengths measured by the photoelectrochemical method show that locally it rises up to 200 μm. We correlate these photovoltaic measurements with the properties of the crystal (defects and purity) by means of measurements by Fourier transform infrared spectroscopy (FTIR) at low temperature (6 K), four probes resistivity technique, scanning electronic microscopy, inductively coupled plasma (ICP), and neutronic activation analyses. We show that the increase of the purity explains the high me asured diffusion lengths. Nevertheless, the thermal conditions of the crystallization of the silicon, due to the specificity of the plasma, lead to defects such as dislocations for which density is particularly high (>10 6 dis/cm 2 ). The results show that chemical reactions between the atomic hydrogen of the plasma and the oxygen of the silicon occur. They decrease the oxygen content in silicon from 3 × 10 17 at./cm 3 down to 2 × 10 16 at./cm 3 , while the residual hydrogen in silicon is close to 2 × 10 15 at./cm 3 . This passivates the dangling bonds of ultrapure silicon with a high thermal stability up to 1000 K. The objective of this paper is to demonstrate that the hydrogen in the plasma modifies the electronic properties of the material to achieve a very good photocurrent even though the dislocation density of the silicon is very high.

Relationship of Microstructure Properties to Oxygen Impurities in Nanocrystalline Silicon Photovoltaic Materials

Tuning Oxygen Impurities and Microstructure of Nanocrystalline Silicon Photovoltaic Materials Through Hydrogen Dilution

Oxygen and Carbon Precipitation in Multicrystalline Solar Silicon

Bonded Hydrogen in Nanocrystalline Silicon Photovoltaic Materials: Impact on Structure and Defect Density

Preparation and Photoluminescence of Nanocrystalline Si-Rich Silicon Oxide Films by Pecvd

Silicon-Oxygen Nanocrystalline Composite Films(nc-SiOx:H)Directly Deposited by Plasma Enhanced Chemical Vapor Deposition

Oxygen and Carbon Behaviors in Multi-Crystalline Silicon and Their Effect on Solar Cell Conversion Efficiency

Bonding of oxygen at the oxide/nanocrystal interface of oxidized silicon nanocrystals: An ab initio study

Microstructure Characterization of Oxidized Nanocrystalline Si:H Film by Transmission Electron Microscopy

Study of microstructure and defects in hydrogenated microcrystalline silicon films

Oxygen Annealing Behavior in Multicrystalline Silicon

Density Functional Theory Study on the Oxidation of Hydrosilylated Silicon Nanocrystals

Photoluminescence, Composition and Microstructure of Porous Silicon Prepared by Different Substrates

The Influence of Microstructure on Optical Properties of Porous Silicon

Enhanced Oxygen Precipitation In Neutron-Irradiated Nitrogen-Doped Czochralski Silicon Crystal

Characterization of the Interface Region During the Agglomeration of Silicon Nanocrystals in Silicon Dioxide

Synergetic effect of gas compositions on material properties of n‐type nanocrystalline silicon oxide prepared by plasma enhanced chemical vapor deposition

Photovoltaic silicon produced by thermal plasma: Influence of atomic hydrogen on oxygen elimination and passivation of the crystal defects

Uniformity And Bandgap Engineering In Hydrogenated Nanocrystalline Silicon Thin Films By Phosphorus Doping For Solar Cell Application

Relation of light stability and microstructure of microcrystalline silicon thin film

Structural Studies on Semiconducting Hydrogenated Amorphous Silicon Oxide Films