Abstract:The growth of high-quality ZnO bulk crystals is an outstanding challenge, and the nature of grown-in defects in crystals is far from well understood. In this work, a specially designed low-temperature-gradient CVT growth system was developed based on finite element analysis. High-quality ZnO single crystals were successfully grown. The supersaturation front in the growth system was controlled, and internal stress in the crystal was reduced by introducing a radiation baffle and a special seed pedestal. The structural, electrical, and optical properties of ZnO crystals were studied before and after oxygen annealing. The scanning electron microscope (SEM) and optical microscope (OM) results indicate the stable growth is achieved under the Zn-rich growth condition. The X-ray rocking curve measurements reveal the high crystalline quality of the grown crystal with the full-width at half-maximum (FWHM) value of 17 arcsec for the (004) reflection. The time-of-flight secondary ion mass spectroscopy (ToF-SIMS) results prove the high purity of grown crystals and reveal the variations of trace impurity concentrations in crystals. When annealed in oxygen at 1000 °C, the optical band gap (Eg) changes from 2.50 eV to 3.15 eV. The Raman analysis indicates that oxygen vacancies (Vo) in the as-grown crystal disappear after annealing. The Hall measurements show that the room temperature (RT) mobilities before and after annealing are 197 cm2V−1c−1 and 207 cm2V−1c−1, respectively. The RT carrier concentration decreases by about two orders of magnitude to 5.45 × 1015 cm−3, while the RT resistivity increases by about one order of magnitude to 5.57 Ω cm after annealing. The positron annihilation lifetimes (PALS) results prove the presence of Zn vacancies (Vzn) after annealing. The origins of as-grown ZnO green luminescence (GL) and the temperature-dependent blue shifts of the GL peak positions are explained based on Zni and Vo defects. The fine structures of annealed ZnO GL are found to be related to Vzn native defects rather than Cu impurity.

Single Crystal Growth of LiGaO_2 by Czochralski Method and Defects Characterization

Study on the Growth Defects of Γ-Lialo2 Crystal

Effect of Pulling Rates on Quality of La2−xBaxCuO4 Single Crystal

Study on Large-size γ-LiAlO2 Single Crystal Grown by Czochralski Technique

Analysis and optimization of Czochralski laser oxide crystal growth

The Anisotropy of Deformation Behaviors in (100) and (010) Plane of Monoclinic 8-Ga2o3 Single Crystals

Growth and Study on Defects of LSO:Ce Scintillation Crystal

Influence of Vapor Transport Equilibration on the Crystal Quality and Thermal-Expansion Coefficients of Γ-Lialo2

Crystal Growth, Characterization, and Properties of Nonlinear Optical Crystals of Li 0.5 Ag 0.5 GaTe 2 for Mid-Infrared Applications

Study on the Growth of Pure and Ga3+ Doped γ-LiAlO2 Crystals

Impurities related micro-defects in GaSb crystal grown by LEC method

Study on the Growth, Modification and Thermal Properties of Γ-Lialo2 Single Crystals

Crystal growth, finite element analysis and oxygen annealing of ZnO bulk crystal grown by low-temperature-gradient chemical vapor transport

Growth, Structural, Thermal, and Optical Properties of a GaNbO4 Single Crystal

Floating Particles in the Melt during the Growth of <i></i>-Ga<sub>2</sub>O<sub>3</sub> Single Crystals Using the Czochralski Method

THE GROWTH OF LARGE SINGLE CRYSTAL OF LnBa2Cu3O7-δ AND THEIR SUPERCONDUCTIVITY

Grown-in Defects in Heavily Phosphorus-Doped Czochralski Silicon

Crystal growth and thermal properties of a LiY(MoO 4 ) 2 crystal

Defect characteristics of ZnO film grown on (0001) sapphire with an ultrathin gallium wetting layer

Crystal growth and design of Sn-doped β-Ga2O3: Morphology, defect and property studies of cylindrical crystal by EFG

The anisotropy dependence of deformation mechanism of cleavage planes in β-Ga2O3 single crystal