Abstract:Recognizing that speed, size, reliability, and cost are the principal driving forces for advanced electronic packages, this review article describes the much needed development of a new, phase transformation-free, single-phase silica dielectric with a dielectric constant (k) of about 4, the lowest among the inorganic oxides, and a coefficient of thermal expansion (CTE) of about 3 ppm/degrees C, similar to that of Si. This dielectric, consisting largely of SiO2, represents a gain in media speed by about 50% over alumina dielectric, combined with an improvement in reliability of the package by a factor of about 1000. The feature size and system cost can also be drastically reduced by using this dielectric. It is made from a mixture of binary borosilicate glasses that normally exhibit an undesirable characteristic of precipitating cristobalite during sintering that severely weakens the structure. The most important aspect of this article is the design and development of a strategy that prevents the cristobalite growth by incorporating a crystal growth inhibitor in the binary mixture of glasses. Since kinetics, not thermodynamics, are shown to be the key to success of this strategy, the roles of rate-controlling parameters are deliberately emphasized. A working model is delineated to identify compositions that yield a cristobalite-free silica dielectric with values of CTE that match those of Si and GaAs. Critical issues of co-firing between metals and this dielectric are addressed within the context of multilayer packaging fabrication. Finally, a list of measured properties is presented that clearly shows new opportunities for this silica dielectric.

Synthesis and Evaluation of Pure-Silica-Zeolite Bea As Low Dielectric Constant Material for Microprocessors

Pure Silica Zeolite Films as Low-k Dielectrics by Spin-On of Nanoparticle Suspensions

Synthesis and Characterization of Pure-Silica-zeolite Beta Low-K Thin Films

20-P-11 Pure-silica Zeolite Low-K Dielectric Thin Films by Spin-on Process

Low‐k Dielectric Materials Derived from ZSM‐5 Zeolite

Thermal Stability and Electrical Properties of Zr Silicate Films for High- K Gate-Dielectric Applications, As Prepared by Pulsed Laser Deposition

High-Surface-Area Zeolitic Silica with Mesoporosity

Hydrothermal Synthesis of Ordered Mesoporous Silicas with Extraordinarily Ultra-low Dielectric Constants

Pulsed Laser Deposition of Zirconium Silicate Thin Films As Candidate Gate Dielectrics

Low dielectric constant films deposited by PECVD using tetraethoxysilane and limonene as precursors

An ultralow-k dielectric derived from a fluorinated polybenzoxazole composite film with yolk–multishell mesoporous silica nanostructures

Atmospheric Pressure Alkaline Etching of MFI Zeolite Under Mild Temperature Toward Hollow Microstructure and Ultralow k Film

Phase purifying and dielectric improvement in Zn2SiO4 ceramics via simply controlling the particle size of SiO2

Investigation of PTFE-based ultra-low dielectric constant composite substrates with hollow silica ceramics

Crystalline SrZrO3 Deposition on Ge (001) by Atomic Layer Deposition for High-K Dielectric Applications

Low-T Sintering, Low-Dielectric Materials for High Frequency Multilayer Chip Inductors

Sintering and microwave dielectric properties of LTCC-zinc titanate multilayers

Synthesis and Microwave Dielectric Properties of BBSZ-Zinc Silicate Based Material for LTCC Applications

Principles of the development of a silica dielectric for microelectronics packaging

Low Dielectric Constant Borophosphosilicate Glass–ceramics Derived from Sol–gel Process

Fabrication and Characterization of Zr-Rich Zr-Aluminate Films for High-Kappa Gate Dielectric Applications