Abstract:The cyclone separator has a simple structure but cannot effectively separate respirable dust of smaller particle sizes. The cartridge filter has a high separation efficiency, but its pressure drop increases too rapidly, requiring frequent cleaning operations. To make up for these defects, a novel cartridge-filtering cyclone combining both cyclone separator and cartridge filter is presented. Its performance parameters, including pressure drop, overall separation efficiency, grading efficiency, and cleaning interval, were studied experimentally and compared with those of the common cyclone and cartridge filter. The cartridge-filtering cyclone first pre-separates the larger particles by swirling airflow, and then filters out the fine particles through the filter cartridges, thus slowing down the increasing rate of the pressure drop and forming denser dust layers attached to the surface of the filter cartridges. The experimental results show that the cartridge-filtering cyclone has a better dust removal effect. At an inlet flow rate of 50 m(3)/h, the separation efficiency of the cartridge-filtering is 99.86%, which is 15.32% and 0.05% higher than that of the common cyclone and cartridge filter, respectively. In particular, the cartridge-filtering cyclone has a preferable separation effect on fine particles, with a separation efficiency for 2.5 mu m particles of 99.11%, which is 70.80% and 0.08% higher than that of the common cyclone and cartridge filter, respectively. Compared with the cartridge filter, the cleaning interval of the cartridge-filtering cyclone is extended and the total dust emission is reduced. Over the whole experimental period, the average cleaning interval and dust emission concentration of the cartridge-filtering cyclone are 1290.05 seconds and 12.06 mg/m(3) respectively, while that of the cartridge filter are 80532 seconds and 14.59 mg/m(3), respectively. (C) 2018 Elsevier B.V. All rights reserved.

Efficient Cyclone Dust Collecting Equipment

Micro Gas Cyclone Design and Performance Evaluation to Collect Dust Particles

Introduction and Simulation of a Small Electro Cyclone for Collecting Indoor Pollen Particles

Analysis of the Performance of a Novel Dust Collector Combining Cyclone Separator and Cartridge Filter

Improvement and Analysis on Cyclone Dust Collector

Performance Evaluation of a New Micro Gas Cyclone Using Simulation and Experimental Studies to Capture Indoor Fine Particles

Design of Anti-explosion Sufur-dust Multi Cyclone

High-efficiency long-life cyclone dust collector

Wet-type whirlwind dust collector

Particle trap effect-based dust collection polar plate and high-efficiency electrostatic dust collector

Dust Removal Principle and Numerical Simulation of New Type Cyclone-bag Combined Dust Collector

Three-stage cyclone separation dust collector

Performance experiments and pressure drop prediction modelling of an energy-saving cyclone separator

Dust collection polar plate based on particle trap effect, novel polarity form and efficient electrostatic dust collector

Inlet Particle-Sorting Cyclone for the Enhancement of PM2.5 Separation

Cyclone dust collector with double ash discharge structure

Cyclonic Separation Technology: Researches and Developments

Performance and techno-economic evaluation of a high-efficiency electrospray cyclone

Design of Attrition Resistant Cyclone Dust Collector

Volute cyclone dust collector

The Effect of Cylinder Structure on the Pre-Dusting of Axial Separator