Abstract:In the presence of a catalyst, the reforming of biomass tar to produce syngas, and its further use for chemical production, is a sustainable energy technology. However, to the best of our knowledge, the integration of tar reforming and downstream technology is still limited. In this work, an economical Ni/biochar catalyst was prepared and successfully applied for steam reforming of toluene (as a tar model compound) and syngas methanation. Under experimental conditions, the Ni/wheat straw (Ni/WS) char catalyst is active for syngas production and further for methane production in a wide temperature range. The physicochemical properties of the Ni/WS char catalyst were carefully characterized, and then the activity, stability, and deactivation of Ni/WS char in toluene reforming and methanation were elaborated. Ni/WS char possessed a smaller Ni crystallite size, and its lower activation energy resulted in higher toluene conversion (90.2%) and gas yield (261.4 mmol/gtoluene) compared with the commercial Ni/Al2O3 catalyst during toluene reforming. Furthermore, the produced syngas with an optimized H2/CO ratio of 3.01 was proved to be suitable for methane production over Ni/WS char, which therefore showed a high CO conversion (80.3%).The Supporting Information is available free of charge at https://pubs.acs.org/doi/10.1021/acssuschemeng.1c03497.Proximate and ultimate analyses of wheat straw; activity comparison and reaction conditions of different Ni-based catalysts in toluene reforming; activity comparison and reaction conditions of different Ni-based catalysts in CO methanation; weight changes of spent Ni/WSC-R and Ni/Al2O3-R at different temperatures and different S/C ratios; weight changes of spent Ni/WSC-R and Ni/Al2O3-R after 15 h TOS of SRT; TG curves of spent Ni/WSC-R and spent Ni/Al2O3-R (after 15 h TOS of SRT) and spent Ni/WSC-M and Ni/Al2O3-M (after 50 h TOS of methanation); weight changes of spent Ni/WSC-M and Ni/Al2O3-M at different temperatures and after 50 h TOS of methanation (PDF)This article has not yet been cited by other publications.

Steam reforming of aromatics mixture as a model tar over Ni/Al 2 O 3 structured catalyst

Steam Reforming of Biomass Tar Model Compounds over Monolithic Catalysts

Influence of Support on Catalytic Behavior of Ni-Based Catalysts in Steam Reforming of Toluene

Optimal Fe/Ni/ Ca‐Al catalyst for tar model steam reforming by using the Taguchi method

Steam Reforming of Tar Model Compounds Over Nickel Catalysts Supported on Barium Hexaaluminate

Enhanced H 2 -Rich Gas Production via Steam Reforming of Toluene over Ni-Based Hydrotalcite-Derived Catalysts at Low Temperature

Low-temperature Catalytic Steam Reforming of Toluene As a Biomass Tar Model Compound over Three-Dimensional Ordered Macroporous Ni-Pt/Ce1−xZrxO2 Catalysts

Catalytic Steam Reforming of Biomass Tar Model Compounds with Low Cost Catalysts: Effect of Operation Conditions

Noble metal (Pt, Pd and Rh) promoted Ni-Co/Mg(Al)O catalysts for steam reforming of tar impurities from biomass gasification

Carbon-coated mesoporous silica-supported Ni nanocomposite catalyst for efficient hydrogen production via steam reforming of toluene

Steam reforming of toluene over Ni–Co/modified-activated carbon catalyst for hydrogen production: Thermodynamic and experimental analysis

Comparative evaluation of tar steam reforming over graphitic carbon supported Ni and Co catalysts at low temperature

Influence of Supports on Catalytic Behavior of Nickel Catalysts in Carbon Dioxide Reforming of Toluene As a Model Compound of Tar from Biomass Gasification.

Recent progress in the development of catalysts for steam reforming of biomass tar model reaction

Highly efficient steam reforming of biomass tar model compound using a high-entropy alloy-based structured catalyst

Highly efficiency H 2 production for real coal tar steam reforming over Ni-ca/H-Al catalyst: Effects of oxygen vacancy, CaO doping and synthesis methods

Low-Temperature Steam Reforming of Toluene and Biomass Tar over Biochar-Supported Ni Nanoparticles

Steam reforming of toluene as model compound of biomass pyrolysis tar for hydrogen

Direct Conversion of Syngas Produced from Steam Reforming of Toluene into Methane over a Ni/Biochar Catalyst

Oxygen Vacancy Induced Strong Metal-Support Interactions on Ni/Ce0.8Zr0.2O2 Nanorod Catalysts for Promoting Steam Reforming of Toluene: Experimental and Computational Studies.

Rare Earth (Gd, Pr and La) Promoted Three-Dimensional Ordered Macro/Mesoporous Ni/CeZr Catalysts for Low-Temperature Catalytic Steam Reforming of Toluene as Tar Model