Abstract:High boiling point heavy tar compounds such as pyrene and naphthalene are key factors causing corrosion and blockage in the pipelines of biomass thermal utilization equipment, and catalytic reforming represents an effective means to address heavy tar issues. Biomass carbon, characterized by its cost-effectiveness, high efficiency, and environmental friendliness, is envisioned as a catalyst carrier with extensive application prospects. In this study, the tar produced by a biomass fixed-bed gasifier was investigated, with an initial analysis of the pyrolysis process and definition of its different stages conducted. It was discovered that the condensation and secondary cracking stages are the predominant phases for the formation of heavy tars, including polycyclic aromatic hydrocarbons (PAHs). Carbon-based carriers were prepared using apricot shell as the raw material, and biomass carbon-based catalysts were synthesized via impregnation methods. The heavy tar extracted from the original tar through distillation was utilized in the hydrogen production tests of steam catalytic reforming with biomass carbon-based catalysts. The investigation into the impact of temperature, steam-to-tar mass ratio (S/T), and tar-to-catalyst mass ratio (T/C) on the catalytic reforming of tar has been conducted. In considering a variety of parameters, including hydrogen production rate, tar conversion rate, and the volume of hydrogen generated, it was found that under the conditions of 800 °C, S/T = 3, and T/C = 2, the Ni/C catalyst yielded the highest amount of hydrogen (91.52 g H2/kg tar) with a tar conversion rate of 93.30 %. The Ni-Co/C composite catalyst exhibited stronger catalytic activity and superior deactivation resistance compared to the monometallic catalysts. For the latter, steam regeneration methods effectively restored the catalytic activity of the carbon-based catalysts, enhancing the hydrogen yield rates of Ni/C and Co/C catalysts by 2.74 and 1.55 times respectively.

Steam reforming of toluene as model compound of biomass pyrolysis tar for hydrogen

Steam Reforming of Biomass Tar Model Compounds over Monolithic Catalysts

Photothermal Steam Reforming: A Novel Method for Tar Elimination in Biomass Gasification

Catalytic Steam Reforming of Biomass Tar Model Compounds with Low Cost Catalysts: Effect of Operation Conditions

Steam reforming of biomass tar model compound over two waste char-based Ni catalysts for syngas production

Steam reforming of toluene as biomass tar model compound in a gliding arc discharge reactor

Experimental study on hydrogen production from heavy tar in biomass gasification furnace catalyzed by carbon-based catalysts

Tar steam reforming during biomass gasification: kinetic model and reaction pathway

Optimization of Operating Parameters for Tar Reforming/hydrogen Upgrading in Corn Straw Pyrolysis Polygeneration

Low-Temperature Steam Reforming of Toluene and Biomass Tar over Biochar-Supported Ni Nanoparticles

Steam Reforming of Tar Studied in Bench-Scale Experiments and Pilot-Scale Tests with Simulations

Hydrogen production from catalytic steam reforming of toluene over trace of Fe and Mn doping Ni/Attapulgite

Slow pyrolysis experimental investigation of biomass tar formation and hydrogen production by tar reforming

Enhanced H 2 -Rich Gas Production via Steam Reforming of Toluene over Ni-Based Hydrotalcite-Derived Catalysts at Low Temperature

Recent progress in the development of catalysts for steam reforming of biomass tar model reaction

Steam Reforming of Toluene and Naphthalene As Tar Surrogate in a Gliding Arc Discharge Reactor.

Catalytic Steam Reforming of Benzene as a Bio-tar Model Compound over Ni–Fe/TiO 2 Catalysts

Enhanced Reforming of Mixed Biomass Tar Model Compounds Using a Hybrid Gliding Arc Plasma Catalytic Process

Steam reforming of aromatics mixture as a model tar over Ni/Al 2 O 3 structured catalyst

Steam reforming of biomass gasification tar over Ni-based catalyst supported by TiO2-SiO2 composite

Recent progress on catalyst development in biomass tar steam reforming: toluene as a biomass tar model compound