Abstract:High boiling point heavy tar compounds such as pyrene and naphthalene are key factors causing corrosion and blockage in the pipelines of biomass thermal utilization equipment, and catalytic reforming represents an effective means to address heavy tar issues. Biomass carbon, characterized by its cost-effectiveness, high efficiency, and environmental friendliness, is envisioned as a catalyst carrier with extensive application prospects. In this study, the tar produced by a biomass fixed-bed gasifier was investigated, with an initial analysis of the pyrolysis process and definition of its different stages conducted. It was discovered that the condensation and secondary cracking stages are the predominant phases for the formation of heavy tars, including polycyclic aromatic hydrocarbons (PAHs). Carbon-based carriers were prepared using apricot shell as the raw material, and biomass carbon-based catalysts were synthesized via impregnation methods. The heavy tar extracted from the original tar through distillation was utilized in the hydrogen production tests of steam catalytic reforming with biomass carbon-based catalysts. The investigation into the impact of temperature, steam-to-tar mass ratio (S/T), and tar-to-catalyst mass ratio (T/C) on the catalytic reforming of tar has been conducted. In considering a variety of parameters, including hydrogen production rate, tar conversion rate, and the volume of hydrogen generated, it was found that under the conditions of 800 °C, S/T = 3, and T/C = 2, the Ni/C catalyst yielded the highest amount of hydrogen (91.52 g H2/kg tar) with a tar conversion rate of 93.30 %. The Ni-Co/C composite catalyst exhibited stronger catalytic activity and superior deactivation resistance compared to the monometallic catalysts. For the latter, steam regeneration methods effectively restored the catalytic activity of the carbon-based catalysts, enhancing the hydrogen yield rates of Ni/C and Co/C catalysts by 2.74 and 1.55 times respectively.

Slow pyrolysis experimental investigation of biomass tar formation and hydrogen production by tar reforming

Experimental study on hydrogen production from heavy tar in biomass gasification furnace catalyzed by carbon-based catalysts

Experimental study on catalytic pyrolysis of biomass over a Ni/Ca-promoted Fe catalyst

Pyrolysis of biomass Tar model compound with various Ni-based catalysts: Influence of promoters characteristics on hydrogen-rich gas formation

Experimental Study on Catalytic and Thermal Cracking of Tar from Biomass Pyrolysis

Catalytic Pyrolysis of Tar Model Compound with Various Bio-Char Catalysts to Recycle Char from Biomass Pyrolysis

Steam Reforming of Biomass Tar Model Compounds over Monolithic Catalysts

Synergistic effect of hydrogen atmosphere and biochar catalyst on tar decomposition and methane-rich gas production during biomass pyrolysis

Catalytic pyrolysis of toluene as biomass tar model component using Ni/HZSM-5 modified by CeO2 and MgO promoters

Steam reforming of biomass tar model compound over two waste char-based Ni catalysts for syngas production

Optimization of Operating Parameters for Tar Reforming/hydrogen Upgrading in Corn Straw Pyrolysis Polygeneration

Synthesis of biomimetic monolithic biochar-based catalysts for catalytic decomposition of biomass pyrolysis tar

Low-Temperature Catalytic Cracking of Biomass Gasification Tar over Ni/HZSM-5

Steam reforming of toluene as model compound of biomass pyrolysis tar for hydrogen

CATALYTIC CRACKING OF TAR DERIVED FROM BIOMASS PYROLYSIS

The Removal of Tar and the Production of Methane-Rich Gas from Biomass Hydrogen Pyrolysis by Using Biochar-Based Catalysts

Pyrolysis Char Derived from Waste Peat for Catalytic Reforming of Tar Model Compound

Steam reforming of biomass gasification tar over Ni-based catalyst supported by TiO2-SiO2 composite

Tar Removal in Pine Pyrolysis Catalyzed by Bio-Char Supported Nickel Catalyst

Maximizing production of high-quality tar from catalytic upgrading of lignite pyrolysis volatiles over Ni-xCe/Y under CH4/CO2 atmosphere

Low-Temperature Steam Reforming of Toluene and Biomass Tar over Biochar-Supported Ni Nanoparticles