Abstract:Bulk lifetime studies of crystalline silicon wafers, e.g. with the aim of studying the light-induced degradation and regeneration behavior, require low-temperature surface passivation schemes that do not alter the silicon bulk properties, e.g. through hydrogenation. Aluminum oxide (Al2O3) can provide an excellent and stable surface passivation, however, in order to achieve the best possible surface passivation, an annealing step at ∼400°C is typically required, which has been found to alter the bulk properties of some silicon materials. Hence, in this contribution we examine the possibility of passivating the silicon surface using Al2O3 layers that have seen a much lower thermal budget. We demonstrate that we are able to achieve an excellent silicon surface passivation using atomic-layer-deposited Al2O3 with measured effective surface recombination velocities Seff as low as 1.3 cm/s without exceeding a temperature of 250°C. We are able to achieve such excellent low-temperature passivation by applying a post-deposition annealing step at 250°C in combination with the deposition of negative Corona charges on the Al2O3 surface. For samples annealed at only 220°C, we still reach very low Seff values of 2 cm/s after deposition of negative Corona charges. We demonstrate that the Corona-charged low-temperature Al2O3 passivation shows only a slight degradation from an Seff of 1.6 cm/s to an Seff of 5 cm/s after 218 days of storage. Even without any post-deposition anneal and only negative Corona charges deposited, we achieve stable Seff values of 15 cm/s. As an alternative to Corona charging, a short exposure to intense UV light (λ = 395 nm) also significantly improves the surface passivation quality of low-temperature-annealed Al2O3-passivated silicon samples. However, the best surface passivation for the latter method is limited to an Seff value of 6.6 cm/s, which is still quite reasonable for bulk lifetime studies.

Passivation with sputtered silicon nitride and modified heat treatment for lifetime improvement

Improved Surface Passivation of Rear SiN x /AlO x Stacks in p-Type Boron-Doped Czochralski Silicon Wafers During Dark Annealing at Elevated Temperatures

Long-term stability study of the passivation quality of polysilicon-based passivation layers for silicon solar cells

Improved Surface Passivation of Rear SiN X /alo X Stacks in P‐type Boron‐Doped Czochralski Silicon Wafers During Dark Annealing at Elevated Temperatures

The Effect and Mechanism of Current Injection to Suppress Light and Elevated Temperature Induced Degradation in P-Type Cast-Mono and Multicrystalline Silicon Passivated Emitter and Rear Cells

Significant Lifetime Improvement of Negative Bias Thermal Instability by Plasma Enhanced Atomic Layer Deposition SiN in Stress Memorization Technique

Impact of Post-deposition Plasma Treatment on Surface Passivation Quality of Silicon Nitride Films

Effect of PECVD silicon oxynitride film composition on the surface passivation of silicon wafers

Kinetics of light and elevated temperature-induced degradation in cast mono p-type silicon

Impact of PECVD SiON stoichiometry and post-annealing on the silicon surface passivation

Study on the Passivation of Si Surface by Incorporation of Nitrogen in Al 2 O 3 Thin Films Grown by Atomic Layer Deposition

Enhanced Si Passivation and PERC Solar Cell Efficiency by Atomic Layer Deposited Aluminum Oxide with Two-step Post Annealing

Investigation on the passivated Si/Al2O3 interface fabricated by non-vacuum spatial atomic layer deposition system

Passivation of textured crystalline silicon with small pyramids by silicon nitride films formed by catalytic chemical vapor deposition and phosphorus catalytic impurity doping

In situ Photoluminescence Study of Plasma Effects on Passivation of Crystalline Silicon Coated with Aluminum Oxide

Low-temperature silicon surface passivation for bulk lifetime studies based on Corona-charged Al2O3

New Insights on LeTID/BO-LID in P-Type Mono-Crystalline Silicon

Light- and Elevated Temperature-Induced Degradation and Recovery from Silicon Wafers by the Impact of Hydrogen Treatment

Optimization of the Surface Structure on Black Silicon for Surface Passivation

Improving Silicon Surface Passivation with a Silicon Oxide Layer Grown via Ozonated Deionized Water

Improvement in Characteristics of Low-Temperature Polycrystalline Silicon Thin Film Transistors with High-Efficiency and Low-Damage N2 Plasma Pretreatment