Abstract:As MOSFET devices are scaled down to below 100nm, the gate oxide thickness is required below 2nm. Conventional SiO2 gate dielectric will be replaced due to excessive leakage and poor reliabilit y. Thus, high dielectrics constant (K) gate dielectrics are being studied as an alternative. High-K dielectrics materials such as CeO2, Y2O3, Ta2O5, HfO2, ZrO2, TiO2, Al2O3, SrTiO3(STO), and BaSrTiO3(BST) have are studied . Among them, HfO2 is a promising candidate due to its thermodynamic stabil ity on Si, high dielectric constant ( 25), and relatively large band gap (5.68eV). In the paper, ultra-thin HfO2 gate dielectrics films were fabricated, electrical and reliabili ty properties such as capacitance-voltage (C-V), current-voltage (I-V), stress induce leakage current (SILC) effects and breakdown characteristics were studied. In the experiment, HfO2 capacitor samples have been fabricated using the following process. P-type (100) sili con substrates with 5-8 cm resistivity were cleaned using H2SO4:H2O2 (2:1) solution and HF dip. Thin HfO2 layers were following deposited at room temperature by ion beam sputtering a sintered HfO2 target. Then they were annealed under various temperatures and ambient. After annealing, Pt top electrodes were deposited by sputtering. The area of the capacitors was 5 10cm. The C-V and I-V curves were measured using HP4156B semiconductor parameter analyzer and Keithley590 C-V analyzer. Figure 1 shows the capacitance-voltage (C-V) curves of HfO2 gate dielectrics. The largest value of measured capacitance density in accumulation is Cmax/A=11.6fF/ m. The equivalent oxide thickness (EOT) is about 2.9nm. Comparing capacitances of various annealing temperatures, the capacitance of the sample annealed at 400 is highest. With increase annealed temperatures, EOT increased. Figure 2 shows the current-voltage (I-V) characteristics of HfO2 gate dielectrics. The leakage current of the sample annealed at 800 is lowest, which is about 3.09 10A/cm at –1.5V gate voltage. No distinct SILC effect is obtained. The leakage current of the sample annealed at 400 after 1×10C/cm stress has a very lit tle diversification. With increase annealed temperatures, the leakage current and SILC effect reduced. Figure 3 shows breakdown characteristics of HfO2 dielectrics. The breakdown electric field of HfO2 dielectrics is more than 2×10MV/cm. With increase annealing temperatures, the breakdown voltages decreased. Consequently, ultra-thin HfO2 gate dielectrics (EOT<3nm) were fabricated. All samples annealed under various temperatures and N2 ambient have good electrical characteristic and reliabili ty. With increase annealing temperatures, EOT of increased, the leakage current and SILC effect reduced, the breakdown voltages decreased. References: [1] E.P. Gusev, E. Carier, D.A. Buchanan, M. Gribelyuk, M. Copel, H. Okorn-Schmidt, and C.D. Emic, Microelectronic Engineering 59(2001) 341-349 [2] Wen-jie Qi, Renee Nieh, Byoung Hun Lee, Laegu Kang, Yongjoo Jeon, and Jack C. Lee, Applied Physics Letters, 2000, 77(20): 3269-3271 [3] G.D. Wilk, and R.M. Wallace, Applied Physics Letters, 1999, 74(19): 2854-2856 [4] Kevin X. Zhang, Carlton M. Osbun, IEEE Trans. Electron Devices, 42(12), 1995, 2181-2188 [5] G.D. Wilk, R.M. Wallace, J.M. Anthony, Applied Physics Review, 2001, 89(10): 5243-5275

Hafnium Oxide as Efficient Material for a New Generation Dielectric

High-Temperature Amorphous Hafnia (Hfo2) For Microelectronics

Defect-Stabilized Substoichiometric Polymorphs of Hafnium Oxide with Semiconducting Properties

Novel halogenated cyclopentadienyl hafnium precursor for atomic layer deposition of high-performance HfO2 thin film

Towards an ideal high-κ HfO2-ZrO2-based dielectric

Hafnium Oxide (HfO2) – A Multifunctional Oxide: A Review on the Prospect and Challenges of Hafnium Oxide in Resistive Switching and Ferroelectric Memories

Solution-processed hafnium oxide dielectric thin films for thin-film transistors applications

Comparison of Hafnium Precursors for the MOCVD of HfO 2 for Gate Dielectric Applications

Properties of Hf0.7Zr0.3O2 thin films chemical vapor deposited using a single-source precursor of anhydrous HfxZr1−x(NO34 precursors

Production of a hafnium silicate dielectric layer for use as a gate oxide by solid-state reaction

Lanthanum-Doped Hafnium Oxide: A Robust Ferroelectric Material

Preparation of High-Quality HfO2 Thin Films on SOI Materials

Electrical and Reliability Characteristics of High-Κ HfO 2 Gate Dielectrics

Hollow Hafnium Oxide (HfO2) Fibers: Using an Effective Combination of Sol-Gel, Electrospinning, and Thermal Degradation Pathway

Hafnium carbide formation in oxygen deficient hafnium oxide thin films

Review—Preparation of Hafnium Metal by Electrolysis

Liquid Phase Deposition of Hafnium Oxide Thin Films

Modulation of Oxygen Content and Ferroelectricity in Sputtered Hafnia‐Zirconia by Engineering of Tungsten Oxide Bottom Electrodes

Physical and electrical characteristics of atomic-layer-deposited hafnium dioxide formed using hafnium tetrachloride and tetrakis(ethylmethylaminohafnium)

Back‐End‐of‐Line Compatible Low‐Temperature Furnace Anneal for Ferroelectric Hafnium Zirconium Oxide Formation

Studies on Optical and Electrical Properties of Hafnium Oxide Nanoparticles