Abstract:Proceedings of the Institution of Mechanical Engineers, Part D: Journal of Automobile Engineering, Ahead of Print. To increase the driving range of electric vehicles, the reduction of aerodynamic drag plays an extremely important role. The wheels contribute more than a quarter of the overall aerodynamic drag for electric cars with relatively smooth underbody. As an essential component of the wheel, the aerodynamic performance of tires has also received extensive attention in recent years. This study investigated the influence of four different production tires combined with two rim designs on the vehicle's aerodynamic performance based on an electric SUV. The wind tunnel tests were conducted to evaluate the aerodynamic forces, and the flow field changes around the tires were measured using a 14-hole pressure probe. Then, the dynamic deformation of the tires was captured to reproduce the actual tire geometry for simulation. The reasons for the drag differences caused by varying tires were thoroughly analyzed by comparing simulation and experimental results. The results show that the difference in drag coefficient between tires reaches up to 0.015, and the enlarged upstream separation induced by the front tires also alters the rear wake structure, significantly reducing base pressure. The effect of tire sidewall labeling and separation edge on drag was isolated by simulation, where the labeling protruding from the sidewall raises the drag coefficient by 0.004, accompanied by more vortices, while the separation edge increases the drag by up to 0.005 depending on its strength and number. It was also found that the dynamic deformation expands the size difference between tires, further increasing the drag differences.

Effect of Aircraft Tire Wear on Water Spray and Water Displacement Drag

Numerical Simulation of Water Spray Caused by a Rolling Airplane Tire

Experimental investigation on the characteristics of tire wear particles under different non-vehicle operating parameters

Effects of surface texture deterioration and wet surface conditions on asphalt runway skid resistance

Experiment and Simulation Research on the Fatigue Wear of Aircraft Tire Tread Rubber

Evaluation of Shear Stress Transport, Large Eddy Simulation and Detached Eddy Simulation for the Flow around a Statically Loaded Tire

Evaluation of Vehicle Braking Performance on Wet Pavement Surface using an Integrated Tire-Vehicle Modeling Approach

On Interfacial Deformation and Resistance Characteristics over Superhydrophobic Surfaces: A Numerical Study

An improved SPH scheme for the 3D FEI (Fluid-Elastomer Interaction) problem of aircraft tire spray

Numerical investigation of passive control flow to improve tire hydroplaning performance using a V-riblet non-smooth surface

Experimental and numerical investigation on the influence of different detailed and deformed tires on the aerodynamics of electric vehicles

Pilot analysis of tire tread characteristics and associated tire-wear particles in vehicles produced across distinct time periods

Explicit Dynamic Analysis of Hydroplaning for Tire with Complex Tread Pattern

Finite Element Analysis For Tire Tread Wear Under Typical Loading Conditions

Numerical simulation of effect of bionic V-riblet non-smooth surface on tire anti-hydroplaning

Experimental and numerical research of aircraft tire debris impact on landing gear brake pipe

Influence of wheel spokes structure on the distribution of surface water film during the wading of road vehicle

Reducing temperature, drag load and wear during aircraft tyre spin-up

Effects of turbulence and bush wear on the transient tribo-dynamic characteristics of water-lubricated bearings

An algorithm for estimating the ultimate speed of vehicles on wet roads

Investigation of surface textures deterioration on pavement skid-resistance using hysteresis friction models and numerical simulation method