Abstract:The 3D tri-gate FinFET device architecture is a key transistor scaling to 22nm node and beyond for its excellent short-channel performance[1]. However, compared with planar transistors, it poses greater challenge in the finFET gate etch.[2] As shown in fig.1, the etch needs to stop on top of the fin while etching further down to the STI oxide layer. Therefore, the top of fin needs to endure long time over etch without any structural damage which would adversely affect device performance. What’s more, the gate profile must be vertical and there should not be residual in the corner of gate and fin. It is not an easy task to achieve, at the same time, the three goals of vertical gate profile, no residual in the corner of fin and gate, as well as no structure damage on the top of fin, due to an unavoidable tradeoff. More specifically, vertical gate profile and no residual in the corner of fin demand strong etch function and light polymer, while no structure damage in the top of fin requires weak etch function and heavy polymer, which points to high etch selectivity of silicon to oxide layer. To achieve good etch results, one often falls into this dilemma. As far as we know, few publicly available papers have provided satisfactory solutions to the above- mentioned problem. In this work, we deal with it. The process of gate stack with CD below 30nm is illustrated in fig.2. Then, a HBr/O2 process in transformer coupled plasma is applied to finFET gate etch. As shown in fig.3, gate profile is vertical, fin is well protected and no residual appears in the corner fin. In conclusion, an HBr/O2 plasma etch process of finFET gate with CD below 30nm is investigated.Through appropriate tradeoff , an etch result of vertical gate profile, no residual in the sidewall and corner of fin, no structure damage on the top of fin is achieved.

β-Ga2O3 FinFETs with ultra-low hysteresis by plasma-free metal-assisted chemical etching

Avoiding Plasma Damage: MacEtch Enabled Β-Ga2o3 FinFETs for On-Resistance Reduction and Hysteresis Elimination

Effective Suppression of MIS Interface Defects Using Boron Nitride Toward High-Performance Ta-Doped-β-Ga2O3 MISFETs.

Ga2O3 fin field-effect transistors with on-axis (100)-plane gate sidewalls fabricated on Ga2O3 (010) substrates

First Demonstration of HZO/beta-Ga2O3 Ferroelectric FinFET with Improved Memory Window

Thermal management and switching performance of β-Ga2O3 vertical FinFET with diamond-gate structure

High-Efficiency Millimeter-Wave Enhancement-Mode Ultrathin-Barrier AlGaN/GaN Fin-HEMT for Low-Voltage Terminal Applications

Hysteresis-free and μ s-switching of D/E-modes Ga 2 O 3 hetero-junction FETs with the BV 2 /R on,sp of 0.74/0.28 GW/cm 2

Quasi-two-dimensional β-Ga2O3 field effect transistors with large drain current density and low contact resistance via controlled formation of interfacial oxygen vacancies

Finfet Gate Etch Towards 16nm Node CMOS Technology

Low Reverse Conduction Loss $\beta $-Ga$_{\text{2}}$O$_{\text{3}}$ Vertical FinFET With an Integrated Fin Diode

Ultra-thin AlGaN/GaN HFET with a high breakdown voltage on sapphire substrates

Enhancement-mode Ga2O3 FETs with an unintentionally doped (001) β-Ga2O3 channel layer grown by metal-organic chemical vapor deposition

High-Performance Amorphous InGaZnO Thin-Film Transistor Gated by HfAlOₓ Dielectric with Ultralow Subthreshold Swing

Trench FinFET Nanostructure with Advanced Ferroelectric Nanomaterial HfZrO2 for Sub-60-mV/Decade Subthreshold Slope for Low Power Application

An Optimized FinFET Channel with Improved Line-Edge Roughness and Linewidth Roughness Using the Hydrogen Thermal Treatment Technology

Inaln/Gan Heterostructure Field-Effect Transistors on Fe-Doped Semi-Insulating Gan Substrates

Effects of Ultra-Thin Si-fin Body Widths Upon SOI PMOS FinFETs

High- ${k}$ HfO 2 -Based AlGaN/GaN MIS-HEMTs with Y 2 O 3 Interfacial Layer for High Gate Controllability and Interface Quality

High Performance and Hysteresis-Free a-IGZO Thin Film Transistors Based on Spin-coated Hafnium Oxide Gate Dielectrics

Reducing Off-State and Leakage Currents by Dielectric Permittivity-Graded Stacked Gate Oxides on Trigate FinFETs: A TCAD Study