Abstract:Post deposition annealing of molecular layer-deposited (MLD) hafnicone films was examined and compared to that of hafnium oxide atomic layer-deposited (ALD) films. Hafnicone films were deposited using tetrakis(dimethylamido)hafnium (TDMAH), and ethylene glycol and hafnia films were deposited using TDMAH and water at 120 °C. The changes in the properties of the as-deposited hafnicone films with annealing were probed by various techniques and then compared to the as-deposited and annealed ALD hafnia films. In situ X-ray reflectivity indicated a 70% decrease in thickness and ∼100% increase in density upon heating to 400 °C yet the density remained lower than that of hafnia control samples. The largest decreases in thickness of the hafnicone films were observed from 150 to 350 °C. In situ X-ray diffraction indicated an increase in the temperature required for crystallization in the hafnicone films (600 °C) relative to the hafnia films (350 °C). The changes in chemistry of the hafnicone films annealed with and without UV exposure were probed using Fourier transformed infrared spectroscopy and X-ray photoelectron spectroscopy with no significant differences attributed to the UV exposure. The hafnicone films exhibited lower dielectric constants than hafnia control samples over the entire temperature range examined. The CF4/O2 etch rate of the hafnicone films was comparable to the etch rate of hafnia films after annealing at 350 °C. The thermal conductivity of the hafnicone films initially decreased with thermal processing (up to 250 °C) and then increased (350 °C), likely due to porosity generation and subsequent densification, respectively. This work demonstrates that annealing MLD films is a promising strategy for generating thin films with a low density and relative permittivity.

Film thickness reduction of thermally annealed hydrogenated amorphous silicon prepared with plasma‐enhanced chemical vapor deposition

Thickness Dependence of Properties of Plasma-Deposited Amorphous SiO2 Films

Thermochemical process occurring in PLD-derived SiC films during vacuum annealing

High Rate Deposition of Stable Hydrogenated Amorphous Silicon in Transition from Amorphous to Microcrystalline Silicon

High temperature annealing of hydrogenated amorphous silicon carbide thin films

Microstructures and Carrier Transport Behaviors of Nanocrystalline Silicon Thin Films

Cold Deposition of Large-Area Amorphous Hydrogenated Silicon Films by Dielectric Barrier Discharge Chemical Vapor Deposition

The Effect of Relatively Low Hydrogen Dilution on the Properties of Carbon-Rich Hydrogenated Amorphous Silicon Carbide Films

OPTICAL AND ELECTRICAL PROPERTIES OF ANNEALING SiNx: H THIN FILM

Room Temperature Growth of Hydrogenated Amorphous Silicon Films by Dielectric Barrier Discharge Enhanced Cvd

Chemical, Structural, and Electrical Changes in Molecular Layer-Deposited Hafnicone Thin Films after Thermal Processing

Crystallization of Hydrogenated Amorphous Silicon Thin Films Using Combined Continuous Wave Laser and Thermal Annealing

Study on Crystallization Mechanism of Hydrogenated Silicon Film

Crystallization of amorphous silicon thin films: The effect of rapid thermal processing pretreatment

Microstructure and Conductivity of Large Area Nanocrystalline Silicon Films Grown by Specially Designed Thermal-Assisted Chemical Vapor Deposition

Evaluation Of Microstructures And Carrier Transport Behaviors During The Transition Process From Amorphous To Nanocrystalline Silicon Thin Films

Novel Sandwich Structure for Aluminum Induced Crystallization of Amorphous Silicon Thin Films at Low Temperature

Influence of Ultrathin Amorphous Silicon Layers on the Nucleation of Microcrystalline Silicon Films under Hydrogen Plasma Treatment

Effect of annealing on microstructure and photoluminescence of nano-composite silicon film

Very High Hydrogen Dilution Induced Novel Phenomena of Electronic Transport Properties in Hydrogenated Microcrystalline Silicon-Germanium Thin Films Prepared by Plasma Enhanced Chemical Vapor Deposition Method

Nanocrystalline Si Films and Devices Produced Using Chemical Annealing with Helium