Abstract:Calcite, as the thermodynamically stable phase of calcium carbonate, is a promising low-cost candidate as low-epsilon r epsilon r microwave dielectric ceramics because of its large natural reserve and the strong covalency of C-O bond, while it is difficult to be densified due to the decomposition at about 627 degrees C. In the present work, calcite ceramics with the relative density of 87.8 % and low Qf value of 5,600 GHz were prepared by the room-temperature cold sintering, and the pressure-less sintering at 400-600 degrees C was conducted subsequently. The pressure-less sintering only increases the relative density slightly, while the microstructural evolution including the formation of uniform grains and significant grain growth were observed with increasing the sintering temperature, leading to a dramatic increase in Qf value. The best microwave dielectric properties with epsilon r = 7.60, Qf = 20,200 GHz, and tau f f =-154 ppm/degrees C degrees C at around 12 GHz were obtained in the calcite ceramic sintered at 600 degrees C, indicating the applicable possibility of carbonate ceramics in microwave communications.

Preparation and Microwave Dielectric Properties of Calcite (caco3) Ceramics

Crystal Structure, Infrared Reflectivity Spectra and Microwave Dielectric Properties of CaAl2O4 Ceramics with Low Permittivity

Crystal Structure, Vibrational Spectroscopy, and Microwave Dielectric Properties of CaAl4O7 Ceramics with Low Permittivity

Low temperature fired CaF<sub>2</sub>-based microwave dielectric ceramics with enhanced microwave properties

Preparation and Microwave Dielectric Properties of Cristobalite Ceramics

Effects Of Catio(3)On Microstructures And Properties Of (1-X) Znal2o4-Xmg(2) Tio4 (X=0.1) Microwave Dielectric Ceramics

Low temperature firing and microwave dielectric properties of BaCaV2O7 ceramics

Low temperature fired CaF2-based microwave dielectric ceramics with enhanced microwave properties

Microwave Dielectric Properties of Low Temperature Sintering Ca 5 Mn 4 (VO 4 ) 6 Ceramics

Crystal structure and performance modification of a novel triclinic CaMgP2O7 microwave dielectric ceramic with low sintering temperature

Microwave dielectric properties of CaV 2 O 6 ceramics with low dielectric loss

A novel low firing microwave dielectric ceramic NaCa2Mg 2V3O12

A Microwave Dielectric Ceramic with Ultra-low Dielectric Constant Prepared by Reaction Sintering Method

Low-fired Fluoride Microwave Dielectric Ceramics with Low Dielectric Loss

Sintering characteristics, microstructure and microwave dielectric properties of low-εr CaY2Al4SiO12 composite ceramics

Synthesis of CaAl2xB2O4+3x: Novel Microwave Dielectric Ceramics with Low Permittivity and Low Loss

Low Temperature Sinter-Ability of Microwave Dielectric Ceramics 0.4(Ca<sub>0.61</sub>Nd<sub>0.26</sub>)TiO<sub>3</sub>-0.6(Li<sub>0.5</sub>Sm<sub>0.5</sub>)TiO<sub>3</sub>

LiCa3ZnV3O12: A Novel Low-Firing, High Q Microwave Dielectric Ceramic

Calcination and sintering effects on the microstructure and dielectric properties of CaCu3Ti4O12 ceramics

CALCINING BEHAVIOR OF OXYFLUORIDE GLASS-CERAMICS/SILICON DIOXIDE SYSTEM FOR LTCC

Preparation and properties of low temperature sintered CaO-B 2 O 3 -SiO 2 microwave dielectric ceramics using the solid-state reaction