A Novel Microwave Dielectric Ceramic Ca2Zn4Ti16O38: Preparation and Dielectric Properties.

Fei Zhao,Zhenxing Yue,Jing Pei,Zhilun Gui,Longtu Li
DOI: https://doi.org/10.1016/j.jssc.2006.03.007
IF: 3.3
2006-01-01
Journal of Solid State Chemistry
Abstract:A novel microwave dielectric powder with composition of Ca2Zn4Ti16O38 was synthesized through a citrate sol-gel process. The development of crystalline phases with heat-treating temperature for the gel derived powders was evaluated by using thermo-gravimetric analysis and X-ray powder diffraction analysis techniques. The pure phase of Ca2Zn4Ti16O38 with crichtonite crystal structure was obtained at relatively low temperature of 1000 degrees C. The synthesized powder has high reactivity and the dense ceramics with single crystalline phase were obtained at low sintering temperature of 1100 degrees C. Impedance spectroscopy and microwave dielectric measurements on sintered samples showed the present compound to be a modest dielectric insulator with excellent dielectric properties of epsilon(r)similar to 47-49, Qf value similar to 27,800-31,600 GHz and tau(f)similar to + 45 to + 50 ppm/degrees C. It shows comparable microwave dielectric properties to other moderate-permittivity microwave dielectrics, but much lower sintering temperature of 1100 degrees C. (c) 2006 Elsevier Inc. All rights reserved.
What problem does this paper attempt to address?