Abstract:The present study focuses on pure and antimony (Sb)-doped tin oxide thin film and its influence on their structural, optical, and electrical properties. Both undoped and Sb-doped SnO2 thin films have been grown by using simple, inexpensive pyrolysis spray technique. The deposition temperature was optimized to 450 °C. X-ray diffractions pattern have revealed that the films are polycrystalline and have tetragonal rutile-type crystal structure. Undoped SnO2 films grow along (110) preferred orientation, while the Sb-doped SnO2 films grow along (200) direction. The size of Sb-doped tin oxide crystals changes from 26.3 to 58.0 nm when dopant concentration is changed from 5 to 25 wt%. The transmission spectra revealed that all the samples are transparent in the visible region, and the optical bandgap varies between 3.92 and 3.98 eV. SEM analysis shows that the surface morphology and grain size are affected by the doping rate. All the films exhibit a high transmittance in the visible region and show a sharp fundamental absorption edge at about 0.38–0.40 nm. The maximum electrical conductivity of 362.5 S/cm was obtained for the film doped with 5 wt% Sb. However, the carrier concentration is increased from 0.708 × 1018 to 4.058 × 1020 cm3. The electrical study reveals that the films have n-type electrical conductivity and depend on Sb concentration. We observed a decrease in sheet resistance and resistivity with the increase in Sb dopant concentration. For the dopant concentration of 5 wt% of Sb in SnO2, the Rs and ρ were found minimum with the values of 88.55 (Ω cm−2) and 2.75 (Ω cm), respectively. We observed an increase in carrier concentration and a decrease in mobility with the addition of Sb up to 25 wt%. The highest figure of merit values 2.5 × 10–3 Ω−1 is obtained for the 5wt% Sb, which may be considered potential materials for solar cells' transparent windows.

PREPARATION OF SnO_2∶Sb FILM COATED ON SiO_2-COATED SODA-LIME GLASS BY SOLGEL METHOD AND ITS CHARACTERIZATION

OPTICAL AND ELECTRICAL PROPERTIES OF SnO2:Sb THIN FILMS DEPOSITED BY SOL-GEL PROCESS

The properties of antimony-doped tin oxide thin films by the sol-gel approach

Synthesis and Properties of Pure and Antimony-Doped Tin Dioxide Thin Films Fabricated by Sol–gel Technique on Silicon Wafer

Conductivity and Optical Nonlinearity of Sb Doped Sno2 Films

Microstructure and Electrical Properties of Antimony-Doped Tin Oxide Thin Film Deposited by Sol–gel Process

Surface morphologies and properties of pure and antimony-doped tin oxide films derived by sol–gel dip-coating processing

On the microstructure and electrical properties of undoped and antimony-doped tin oxide thin film deposited by sol-gel process

On the microstructure and electrical properties of undoped and antimony- Doped tin oxide thin film deposited by sol-gel process

Effects of Sb doping on the structure and properties of SnO2 films

Preparation and characterization of ZnO-B2O3-SO2 by sol-gel method

Preparation of Sb:SnO2 thin films and its effect on opto-electrical properties

Dependence of Electrical and Optical Properties of Sol-gel-derived SnO2 Thin Films on Sb-substitution

The Optical and Electrical Properties of Antimony-Doped Tin Oxide Transparent Conducting Thin Films Prepared by Sol-Gel Dip-Coating Technique

Microstructural and Functional Stability of Large-Scale SnO2:F Thin Film with Micro-Nano Structure

Preparation of Sb 2 S 3 film on functional organic self-assembled monolayers by chemical bath deposition

Preparation and Characterization of ZnO-B2O3-SiO2 by Sol-Gel Method

Morphologies and Microstructures of Antimony-Doped Tin Oxide Films Derived by Sol-Gel Dip-Coating Processing

AFM Investigation of Nano Particle Incorporated Sb Doped SnO<sub>2</sub> Films

Structural/microstructural, optical and electrical investigations of Sb-SnO2 thin films deposited by spray pyrolysis