Abstract:The effects of substrate temperature and O-2 flux on structural, electrical, and optical properties of the films prepared by RF reactive magnetron sputtering with SnF2-Sn target have been investigated by X-ray diffraction (XRD), Hall effect measurements, optical transmission spectra, and photoluminescence (PL) spectra. It is found that F-doped SnO films are produced and exhibit amorphous structure at lower O-2 fluxes for substrate temperature of RT-300 degrees C, and window of O2 flux for depositing the films is reduced as substrate temperature increases. F-doped SnO2 (FTO) films are formed at higher O-2 fluxes, and they exhibit amorphous state at substrate temperature of RT but crystalline state at substrate temperature of 150 and 300 degrees C. Furthermore, increasing O-2 flux or substrate temperature can promote crystallinity and affect growth orientation for crystalline FTO films. Highly conductive FTO films can be obtained only at suitable O-2 fluxes and higher substrate temperatures (150 and 300 degrees C), at which the films keep crystalline SnO2 structure along with high amount of oxygen vacancy (V-O). Increasing substrate temperature from 150 to 300 degrees C, the resistivity of FTO films cannot be further decreased due to the out-diffusion of F although the film crystallinity improves. Compared with F-doped SnO films, the average transmittance in visible light range and band gap (E-g) of FTO films obviously increase. The FTO films show similar shaped PL spectra that can be attributed to substitutional fluorine (F-O) and V-O defects in the films, and PL emission intensity increases with increasing O-2 flux or substrate temperature due to the improvement of film crystallinity. It is observed that the PL emission characteristics (shape and intensity) of F-doped SnO film are obviously different from FTO films and they have great changes as substrate temperature from RT to 150 degrees C, but corresponding mechanisms need to further clarify. (C) 2017 Elsevier B.V. All rights reserved.

Effects of Sb doping on the structure and properties of SnO2 films

Sb-doping effects on optical and electrical parameters of SnO2 films

OPTICAL AND ELECTRICAL PROPERTIES OF SnO2:Sb THIN FILMS DEPOSITED BY SOL-GEL PROCESS

Conductivity and Optical Nonlinearity of Sb Doped Sno2 Films

Effect of Sb doping on structural and photoelectric properties of SnO2 thin films

Effect of Sb doping on structural, electrical and optical properties of epitaxial SnO2 films grown on r-cut sapphire

Influence of Dopant Content on Morphology and Optical Constants of ZnO:Na Films by Sol-Gel Method

Preparation of Sb:SnO2 thin films and its effect on opto-electrical properties

Effect of Sb doping on the transport and electrochemical properties of partially amorphous SnO2 thin films

Effect of very low to high Sb-doping on the structural, electrical, photo-conductive and thermoelectric properties of fluorine-doped SnO2 (FTO) thin films prepared by spray pyrolysis technique

Electronic structure and optical properties of Sb-doped SnO2

Optical Properties and Boron Doping-Induced Conduction-Type Change in SnO 2 Thin Films

Effect of Sb Doping on Structure and Humidity Sensing Properties of SnO2 Synthesized by Hydrothermal Method

Bi 2 SiO 5 Doping Concentration Effects on the Electrical Properties of SrBi 2 Ta 2 O 9 Films

Effect of substrate temperature on the structure and properties of SnO2: Sb films

Physical and photoelectrochemical properties of Sb-doped SnO2 thin films deposited by chemical vapor deposition: application to chromate reduction under solar light

Electron–Electron Interactions in Sb-Doped SnO2 Thin Films

Influences of Dopants on the Electronic Structure of Sno2 Thin Films

Structural, morphological, electrical and optical properties of SnO2 nanoparticles: influence of Sb doping

Structural, Electrical, and Optical Properties of F-doped SnO or SnO2 Films Prepared by RF Reactive Magnetron Sputtering at Different Substrate Temperatures and O2 Fluxes

Structural and Electronic Properties of SnO2 Doped with Non-Metal Elements