Abstract:The accurate, repeatable, and verifiable measurement of SO 3 /H 2 SO 4 is significant to the reliability operation of coal-fired power plants, as well as environment protection and human health. Although the amount of SO 3 in flue gas is very small, and its chemical property is extremely active, the measurement of SO 3 /H 2 SO 4 is difficult and problematic. The measurement errors of controlled condensation method for SO 3 /H 2 SO 4 in flue gas were evaluated with a sampling system based on dilute sulfuric acid heating method. In order to improve the test accuracy of this method, the effects of water bath temperature, flue gas sampling flow rate, and spiral condensing tube structure parameters (inner diameter and length of spiral condensing tube) on the recovery efficiency of SO 3 /H 2 SO 4 were investigated. The results indicate that the recovery efficiency fluctuates in the range between 84.1% and 91.6%, with the water bath temperature increasing from 40°C to 90°C. As the flue gas sampling flow rate increases from .5 L/min to 4 L/min, the recovery efficiency of SO 3 /H 2 SO 4 shows a gradual tendency of increasing, and the recovery efficiency can be high up to 98.4%. When the inner diameter of the spiral condensing tube increases from 3 mm to 10 mm, the recovery efficiency of SO 3 /H 2 SO 4 decreases gradually. The recovery efficiency of SO 3 /H 2 SO 4 increases gradually with the spiral condensing tube length increasing from 900 mm to 2000 mm.

Comparison and Analysis on the Calculation Methods of Acid Dew Point of Flue Gas

The Measurement and Correction of Correlation Formulas of Flue Gas Acid Dew Point

Prediction of Acid Dew Point in Flue Gas of Boilers Burning Fossil Fuels

Theoretical Analysis of Acid Dew Point Temperature and Vapour Condensation Characteristics of the Flue Gas

Predicting Acid Dew Point with A Semi-Empirical Model

Wet Flue Gas Desulfurization Process Analysis and Simple Flue Gas Heating Method

Numerical Study on Acid Condensation and Corrosion Characteristics of Three-Dimensional Finned Tube Surface

Parameter analysis on SO3 measurement in coal-fired flue gas with controlled condensation method

Prediction of Sulfuric Acid Dew Point Temperature on Heat Transfer Fin Surface

Analytic Study on Approach to Adiabatic Saturation Temperature and the Control Scheme for the Amount of Water Sprayed in the Semi-Dry FGD Process

ON-LINE CALCULATION METHOD OF EXHAUST STEAM' S ENTHALPY

Thermal calculation method for direct-contact flue-gas-water condensation heat exchangers

Study on Spray Condensation Performance of Desulfurization Wet Flue Gas

Thermodynamic properties calculation of the flue gas based on its composition estimation for coal-fired power plants

Analysis of Main Influencing Factors of the Wastewater Evaporation in Flue Duct

Measurements of Dew Point Temperature of Flue Gas in Circulating Fluidized Bed Reactor for Flue Gas Desulfurization

Calculation modeling of the water vapor saturation curve of moist air and its analysis

Numerical predictions of sulfuric acid corrosion on novel heat transfer surfaces

Comparison study on the calculation formula of evaporation mass flux through the plane vapour-liquid interface

Experimental Study on the Heat Transfer of Convection and Condensation between the Staggered Bank and the Low Temperature Transversal Flow Flue Gas

Optimization Research On The Power Boiler Furnace Performance Design Method