Abstract:The higher voltage blocking capability and faster switching speed of silicon-carbide (SiC) mosfets have the potential to replace Si insulated gate bipolar transistors (IGBTs) in medium-low-voltage and high-power applications. In this paper, a state-of-the-art commercially available 325 A, 1700 V SiC mosfet module has been fully characterized under various load currents, bus voltages, and gate resistors to reveal their switching capability. Meanwhile, Si IGBT modules with similar power ratings are also tested under the same conditions. From the test results, several interesting points have been obtained: different to the Si IGBT module, the over-shoot current of the SiC mosfet module increases linearly with the increase of the load current and it has been explained by a model of the over-shoot current proposed in this paper; the induced negative gate voltage due to the complementary device turn-off (crosstalk effect) is more harmful to the SiC mosfet module than the induced positive gate voltage during turn-on when the gate off-voltage is 6 V; the maximum dvdt and didt (electromagnetic interference) during switching transients of the SiC mosfet module are close to those of the Si IGBT module when the gate resistance is larger than 8 but the switching loss of the SiC mosfet module is much smaller; the switching losses of the Si IGBT module are greater than those of the SiC mosfet module even when the gate resistance of the former is reduced to zero. An accurate power loss model, which is suitable for a three-phase two-level converter based on SiC mosfet modules considering the power loss of the parasitic capacitance, has been presented and verified in this paper. From the model, a 96.2 efficiency can be achieved at the switching frequency of 80kHz and the power of 100 kW.

An Indirect Series-Connected SiC MOSFET Power Module with Voltage Self-Balance

A Quasi-Two-Level Medium-Voltage SiC MOSFET Power Module with Low Loss and Voltage Self-Balance

Design of Low Parasitic Inductance SiC MOSFETs Halfbridge Power Modules

Fabrication and Dynamic Switching Characteristics of 6.5kv400a SiC MOSFET Module

A Compact Gate Control and Voltage-Balancing Circuit for Series-Connected SiC MOSFETs and Its Application in a DC Breaker

Dynamic Performance of 6.5kV/400A SiC MOSFET Module and its Gate Driver

Voltage Balancing Method for Series-Connected SiC MOSFETs under No Load Condition

A Double-Sided Cooling 6.5kv SiC MOSFET Power Module with Insulation Enhancement Design

A Novel SiC MOSFET Module for High-power Soft-switching Converter

An SiC MOSFET & Si Diode Hybrid Three-Phase High-Power Three-level Rectifier

A Novel Gate Control Strategy for 3.4kv Cascade Sic Mosfets Stack

A 10kV/200A SiC MOSFET module with series-parallel hybrid connection

3.38 Mhz Operation of 1.2kv SiC MOSFET with Integrated Ultra-Fast Gate Drive

Analysis and Flexible DV/DT Control of an Active Clamping Topology for Series-Connected SiC MOSFETs

Design and Current Balancing Optimization of A 1700V/1000A Multi-chip SiC Power Module

Performance of a 1.2kV, 288A full-SiC MOSFET module based on low inductance packaging layout

Performance Evaluation of High-Power SiC MOSFET Modules in Comparison to Si IGBT Modules

Design and Application of A 1200v Ultra-Fast Integrated Silicon Carbide Mosfet Module

A 10kV/200A SiC MOSFET module with series-parallel hybrid connection of 1200V/50A dies