Abstract:The gas phase flow field inside a cyclone separator is crucial to the particle separation process. Previous studies have paid attention to the steady-state characteristics of the gas phase flow field, while research on its dynamic characteristics remains insufficient. Meanwhile, cyclone separators often adopt different structural forms according to the process requirements, the evolution laws of the dynamic characteristics flow field within them are still not well understood. Therefore, in this study, a hot-wire anemometer (HWA) was employed to measure the instantaneous tangential velocity of the gas phase flow fields within different structural cyclone separators (cylinder type, cylinder–cone (no hopper), and cylinder–cone (with hopper)). Comparative analyses and discussions were conducted regarding the dynamic characteristic distribution rules of the flow field in the time domain and the frequency domain. The results revealed that the dimensionless tangential velocity distributions of different types of cyclone separators all conformed to the Rankine vortex structure. The instantaneous tangential velocity fluctuated with low frequency and high amplitude, and the low-frequency velocity fluctuation exhibited a transfer behavior along the radial direction. Compared with the cylinder–cone-type cyclone separator, the tangential velocity in the cylinder-type cyclone separator fluctuated more greatly, and its quasi-periodic behavior was also more obvious. The time-averaged tangential velocity, the tangential velocity fluctuation intensity (Sd), and the dominant fluctuation frequency all had obvious attenuation along the axial direction in the cylinder-type cyclone separator, while the above-mentioned parameters had no attenuation along the axial direction in cylinder–cone-type cyclone separators. Additionally, the backflow from the hopper of the cylinder–cone-type cyclone separator (with hopper) led to an increase in the instantaneous tangential velocity fluctuation intensity of the local flow field near the dust outlet, as well as the occurrence of the "double dominant frequencies" phenomenon.

Dynamic Characteristics of Scraper-Discharge Material Centrifuge

Analysis on Dynamic Characteristics and Design of Centrifuge

The Effect on Dish Centrifuge'dynamical Characteristic of the Unbalance Weight of Rotor

Development of Centrifuge for Multi-Parameter Combined Environmental Test

Principal Axis System's Critical Rotating Speed Calculation and Analysis of Dish Centrifuge

The Design of Dynamic Balancing Machine Based on Finite Element Analysis

Rotor Dynamic Characteristic Calculation of the Horizontal Helical-conveyer Centrifuge

Instability of an Over-Hung Rigid Centrifuge Rotor Partially Filled with Fluid

Dynamic Balancing of a Centrifuge: Application to a Dual-Rotor System with Very Little Speed Difference

Investigation of the impact of splitter blades on a low specific speed pump for fluid-induced vibration

Vibration and Aerodynamic Analysis and Optimization Design of a Test Centrifuge

An Experimental Study on Aerodynamic Characteristics of Hypergravity Centrifugal Facility

Experimental Investigation into the Effect of Fluid Viscosity on Instability of an Over-Hung Flexible Rotor Partially Filled with Fluid

A Quasi-Dynamic Model for High-Speed Ball Spinning

Research on the Field Dynamic Balancing Technology and Instrument for a High Speed Cantilever Rotor

Dynamic characteristics of the rotor system for large pump-turbine sets

Application of dynamic centrifuge model test to slope engineering

Study on dynamic characteristics of scraper conveyor under various scraper configurations

Analytical Solution of the Temperature Distribution of the Rotor Wall in the Centrifuge Made of Two Layers Materials

Comparative Analyses of Dynamic Characteristics of Gas Phase Flow Field Within Different Structural Cyclone Separators

Nonlinear Dynamic Analysis of a Rigid Rotor Supported By a Spiral-Grooved Opposed-Hemisphere Gas Bearing