Abstract:Two typical CO2 chemical absorption processes using MEA and aqueous ammonia (AA) solutions to act as absorbents and one novel process using hollow fiber membrane contactors (HFMCs) to act as absorber and MEA as absorbent were analyzed in this study to find out what CO2 capture process may be more suitable for China. An ultra supercritical PC power plant with 840-MWe-gross-output was selected as the reference case without CO2 capture. Economic results show that when membrane price is set at RMB 50/m(2) and lifetime is 5 years, CAPEX of MEA, HFMC and AA cases are increased by about 90.12%, 85.4% and 68%, respectively, compared to reference case. And the corresponding cost of avoided is RMB 305.1/tCO(2), RMB 266.45/tCO(2) and RMB 206.02/tCO(2), respectively. The seemingly positive results imply that AA-based chemical absorption process should be the best for China nowadays. In addition, prospect of HFMC process in the future was also considered based on the increasing anxiety of NH3 slip for AA process. If membrane price can be reduced to less than RMB 20/m(2) and new solvents with similar to 3 GJ/tCO(2) total regeneration heat requirement can be adopted in the future, HFMC may replace the AA-based method to capture CO2. Additionally, economic results also show that the development of new solvents only considering the reduction of heat of CO2 absorption may be not sufficient in terms of the reduction of CO2 avoided cost. That is because CO2 avoided cost can only be reduced by about 8% even the heat of CO2 absorption can be reduced by about 60%. Finally, effects of coal price, improvements of reference case and CO2 capture system on the cost of CO2 avoided were also investigated. (C) 2010 Published by Elsevier Ltd.

Experimental Comparison of Flue Gas CO_2 Separation with Membrane Absorption and Chemical Absorption

Experiments Study of Absorption Solution Performance of CO2 Sequestration in Flue Gas Using Membrane Absorption

CO2 Removal from Air by Hollow-fiber Membrane-based Absorption System

Comparative Analysis of CO2 Separation from Flue Gas by Membrane Gas Absorption Technology and Chemical Absorption Technology in China

Experiment of CO_2 Separation from Flue Gases by Membrane Gas Absorption

Comparison of Dissociation Performance of CO_2 from Flue Gas by Hollow Fiber Membrane Contactors

Removal of CO2 from Simulated Flue Gas of Power Plants by Membrane-Based Gas Absorption Processes

Simulation Study on Separation of CO2 from Flue Gas in Coal-Fired Power Plant by Membrane Method

Separation of CO2 in Flue Gas by Membrane Absorption in China

CO2 separation from flue gases by polypropylene hollow fiber membrane contactor

Experimental studies on simultaneous removal of CO2 and SO2 in a polypropylene hollow fiber membrane contactor

Study on the Mass Transfer Process of Carbon Dioxide Absorption into Monoethanolamine in Flue Gas

Experimental Study and Modified Modeling on Effect of SO2 on CO2 Absorption Using Amine Solution

Performance Analysis of CO2 Separation from Glue Gas with Membrane Absorption Method

Economic Analysis of CO2 Separation from Coal-Fired Flue Gas by Chemical Absorption and Membrane Absorption Technologies in China

Selection of Blended Solvents for CO2 Absorption from Coal-Fired Flue Gas. Part 1: Monoethanolamine (Mea)-Based Solvents

Experimental Study and Numerical Simulation on CO2 Capture from Flue Gas Using Amine-Based Absorbent in Coal-Fired Power Plant

Effects of SO2 on CO2 capture using a hollow fiber membrane contactor

Experimental and Modeling Study of Trace CO2 Removal in a Hollow-Fiber Membrane Contactor, Using CO2-Loaded Monoethanolamine

Experimental Study on the Separation of CO2 from Flue Gas Using Hollow Fiber Membrane Contactors Without Wetting

Engineering Design and Economic Analysis of CO2 Sequestration from Flue Gas by Using Membrane Absorption Techniques