Abstract:Amine scrubbing is currently the most promising technology for CO2 capture from gas turbine and coal-fired flue gas. It is hindered by high regeneration energy and high capital cost. Biphasic solvent of 25% aminoethylethanolamine (AEEA)/50% diethylethanolamine (DEEA) could be a potential solution as it may achieve significant reduction in regeneration energy. A fast CO2 absorption rate is preferred to reduce the capital cost of the absorber. In this work, the CO2 absorption rate (kg′) of the biphasic solvent was measured in a wetted wall column at 40 °C and at the loading conditions in the absorber. At CO2 equilibrium partial pressure (PCO2*) lower than 100 Pa, 25% AEEA/50% DEEA is homogeneous. The CO2 absorption rate, kg′, is as fast as 30% PZ (3 times faster than 30% MEA). When PCO2* is greater than 100 Pa, 25% AEEA/50% DEEA forms aqueous and organic phases after CO2 absorption. It was first found that the organic phase of 25% AEEA/50% DEEA absorbs CO2 2–7 times faster than the aqueous phase because of greater physical CO2 solubility at the same PCO2* and physical mass transfer coefficient. The kg′ of the organic phase is much faster than 30% MEA and 25% AEEA at lean and rich loading and even greater than 30% PZ at lean loading. The instantaneous reaction mechanism fits the kinetics of CO2 absorption in the organic phase at low PCO2*. The slow kg′ of the aqueous phase results from greater viscosity which significantly reduces the physical mass transfer coefficient. The CO2 capacity of the aqueous phase is 2.9 times, 1.8 times, and 5.3 times greater than that of 30% MEA, 30% PZ, and the organic phase, respectively.

Selection of Blended Solvents for CO2 Absorption from Coal-Fired Flue Gas. Part 1: Monoethanolamine (Mea)-Based Solvents

Effect of Operating Parameters on CO 2 Capture from Biogas with Choline Chloride—monoethanolamine Deep Eutectic Solvent and Its Aqueous Solution

Structure-activity Relationship-based Selection of Amine Solvent for CO2 Capture From Coal-fired Flue Gas

Simulation of a CO_2 Capture System Using Amine Solutions for Selection of Absorbents

CO2 absorption rate in biphasic solvent of aminoethylethanolamine and diethylethanolamine

Removal of CO2 from Simulated Flue Gas of Power Plants by Membrane-Based Gas Absorption Processes

Study on absorption and regeneration performance of EHA-DMSO non-aqueous absorbent for CO2 capture from flue gas

Mixed Amine Absorbent based on Hollow Fiber Membrane Contactor Removes CO2 from Flue Gas

Absorption of Carbon Dioxide into Aqueous Blend of Monoethanolamine and 1-Butyl-3-methylimidazolium Tetrafluoroborate

Experimental Study Of Co2 Solubility In High Concentration Mea Solution For Intensified Solvent-Based Carbon Capture

Mixture Absorption System of Monoethanolamine−Triethylene Glycol for CO<sub>2</sub> Capture

Mixture absorption system of monoethanolamine-triethylene glycol for CO 2 capture

Experimental Study on Absorption of Carbon Dioxide in Flue Gas by Monoethanolamine Fine Spray

Heat of absorption of CO 2 in 30 wt% MEA with monoethyleneglycol and urea as vapour reduction additives

Evaluating Solvent Efficiency for Carbon Capture: Comparative Analysis of Temperature, Concentration and Diffusivity Effects

Experimental Study and Modified Modeling on Effect of SO2 on CO2 Absorption Using Amine Solution

Experimental Study on CO2 Absorption in Novel Biphasic Solvents and CO2 Desorption by Novel Direct Non-Aqueous Gas Stripping Process

Solvent selection for CO2 capture from gases with high carbon dioxide concentration

Performance of a Hybrid Solvent of Amino Acid and Ionic Liquid for CO 2 Capture

Industrial test of post combustion CO2 capture by reactive absorption with two new solvents in natural gas power plant

Hybrid Behaviors of CO2 Absorption into Blended DEEA‐based Solution for the Improvement of Capture Performance