Abstract:Two typical CO2 chemical absorption processes using MEA and aqueous ammonia (AA) solutions to act as absorbents and one novel process using hollow fiber membrane contactors (HFMCs) to act as absorber and MEA as absorbent were analyzed in this study to find out what CO2 capture process may be more suitable for China. An ultra supercritical PC power plant with 840-MWe-gross-output was selected as the reference case without CO2 capture. Economic results show that when membrane price is set at RMB 50/m(2) and lifetime is 5 years, CAPEX of MEA, HFMC and AA cases are increased by about 90.12%, 85.4% and 68%, respectively, compared to reference case. And the corresponding cost of avoided is RMB 305.1/tCO(2), RMB 266.45/tCO(2) and RMB 206.02/tCO(2), respectively. The seemingly positive results imply that AA-based chemical absorption process should be the best for China nowadays. In addition, prospect of HFMC process in the future was also considered based on the increasing anxiety of NH3 slip for AA process. If membrane price can be reduced to less than RMB 20/m(2) and new solvents with similar to 3 GJ/tCO(2) total regeneration heat requirement can be adopted in the future, HFMC may replace the AA-based method to capture CO2. Additionally, economic results also show that the development of new solvents only considering the reduction of heat of CO2 absorption may be not sufficient in terms of the reduction of CO2 avoided cost. That is because CO2 avoided cost can only be reduced by about 8% even the heat of CO2 absorption can be reduced by about 60%. Finally, effects of coal price, improvements of reference case and CO2 capture system on the cost of CO2 avoided were also investigated. (C) 2010 Published by Elsevier Ltd.

Removal of CO2 from Simulated Flue Gas of Power Plants by Membrane-Based Gas Absorption Processes

CO2 Removal from Air by Hollow-fiber Membrane-based Absorption System

CO2 separation from flue gases by polypropylene hollow fiber membrane contactor

Mixed Amine Absorbent based on Hollow Fiber Membrane Contactor Removes CO2 from Flue Gas

Mass Transfer Process of Co2 Absorption Through Non-Porous Hollow Fibre Contactor

Comparative Analysis of CO2 Separation from Flue Gas by Membrane Gas Absorption Technology and Chemical Absorption Technology in China

Experimental Study on the Separation of CO2 from Flue Gas Using Hollow Fiber Membrane Contactors Without Wetting

Microporous polypropylene hollow fiber membranes contactor for the separation and fixation of carbon dioxide from simulative flue gas

Experimental study on the absorption of CO 2 from flue gas by aqueous solutions of methyldiethanolamine + potassium glycinate in hollow fiber membrane contactor

Understanding the performance of membrane for direct air capture of CO2

Experimental Comparison of Flue Gas CO_2 Separation with Membrane Absorption and Chemical Absorption

A Comprehensive Parametric Study on CO2 Removal from Natural Gas by Hollow Fiber Membrane Contactor: A Computational Fluid Dynamics Approach

Experimental and Modeling Study of Trace CO2 Removal in a Hollow-Fiber Membrane Contactor, Using CO2-Loaded Monoethanolamine

Selection of Blended Solvents for CO2 Absorption from Coal-Fired Flue Gas. Part 1: Monoethanolamine (Mea)-Based Solvents

Economic Analysis of CO2 Separation from Coal-Fired Flue Gas by Chemical Absorption and Membrane Absorption Technologies in China

Simulation of a CO_2 Capture System Using Amine Solutions for Selection of Absorbents

Experiments Study of Absorption Solution Performance of CO2 Sequestration in Flue Gas Using Membrane Absorption

Co(2) Chemical Absorption by Using Membrane Vacuum Regeneration Technology

CO2 Capture by Using a Membrane-absorption Hybrid Process in the Nature Gas Combined Cycle Power Plants

Modeling and simulation of CO2 removal from power plant flue gas by PG solution in a hollow fiber membrane contactor

Separation of CO2 in Flue Gas by Membrane Absorption in China