Abstract:Amine scrubbing is currently the most promising technology for CO2 capture from gas turbine and coal-fired flue gas. It is hindered by high regeneration energy and high capital cost. Biphasic solvent of 25% aminoethylethanolamine (AEEA)/50% diethylethanolamine (DEEA) could be a potential solution as it may achieve significant reduction in regeneration energy. A fast CO2 absorption rate is preferred to reduce the capital cost of the absorber. In this work, the CO2 absorption rate (kg′) of the biphasic solvent was measured in a wetted wall column at 40 °C and at the loading conditions in the absorber. At CO2 equilibrium partial pressure (PCO2*) lower than 100 Pa, 25% AEEA/50% DEEA is homogeneous. The CO2 absorption rate, kg′, is as fast as 30% PZ (3 times faster than 30% MEA). When PCO2* is greater than 100 Pa, 25% AEEA/50% DEEA forms aqueous and organic phases after CO2 absorption. It was first found that the organic phase of 25% AEEA/50% DEEA absorbs CO2 2–7 times faster than the aqueous phase because of greater physical CO2 solubility at the same PCO2* and physical mass transfer coefficient. The kg′ of the organic phase is much faster than 30% MEA and 25% AEEA at lean and rich loading and even greater than 30% PZ at lean loading. The instantaneous reaction mechanism fits the kinetics of CO2 absorption in the organic phase at low PCO2*. The slow kg′ of the aqueous phase results from greater viscosity which significantly reduces the physical mass transfer coefficient. The CO2 capacity of the aqueous phase is 2.9 times, 1.8 times, and 5.3 times greater than that of 30% MEA, 30% PZ, and the organic phase, respectively.

What problem does this paper attempt to address?

The main problems that this paper attempts to solve are to increase the carbon dioxide (CO₂) absorption rate and reduce the regeneration energy consumption, so as to optimize the application of amine solvents in CO₂ capture from flue gas. Specifically: 1. **Increasing the CO₂ absorption rate**: Although traditional single - phase amine solvents such as 30% monoethanolamine (MEA) are widely used, their absorption rate is slow, which leads to an increase in the volume of the absorption tower and an increase in the capital cost of the equipment. Therefore, the research aims to develop a new solvent system with a faster CO₂ absorption rate. 2. **Reducing the regeneration energy consumption**: The regeneration process of traditional amine solvents requires a large amount of energy, which is an important bottleneck in CO₂ capture technology. The paper proposes a two - phase solvent system composed of 25% aminoethylethanolamine (AEEA) and 50% diethylethanolamine (DEEA), and this solvent system is expected to significantly reduce the regeneration energy consumption. 3. **Exploring the behavior of the two - phase solvent**: When CO₂ is absorbed, the 25% AEEA/50% DEEA solvent will form an aqueous phase and an organic phase. The paper has studied in detail the behavior of these two phases under different CO₂ loads, especially their influence on the CO₂ absorption rate. ### Specific problems and solutions - **Measurement of the CO₂ absorption rate**: Through the wetted - wall column experiment, the CO₂ absorption rate (\( k_g' \)) of the 25% AEEA/50% DEEA solvent under different CO₂ loads was measured and compared with the traditional MEA and PZ solvents. - **Physical solubility and diffusion coefficient**: The physical solubility of CO₂ in different amine solutions was calculated by using the N₂O analogy method, and the diffusion coefficient of CO₂ in these solutions was determined by experiments. - **Mass transfer coefficient**: The absorption process of CO₂ in amine solutions was explained by the double - film theory, and the total mass transfer coefficient (\( K_G \)), the gas - phase mass transfer coefficient (\( k_g \)) and the liquid - phase mass transfer coefficient (\( k_g' \)) were calculated. ### Main findings - When the CO₂ equilibrium partial pressure (\( P_{CO_2}^* \)) is lower than 100 Pa, 25% AEEA/50% DEEA is homogeneous, and its CO₂ absorption rate is equivalent to that of 30% PZ and three times faster than that of 30% MEA. - When \( P_{CO_2}^* \) is greater than 100 Pa, 25% AEEA/50% DEEA forms an aqueous phase and an organic phase, in which the CO₂ absorption rate of the organic phase is 2 - 7 times faster than that of the aqueous phase, mainly due to the higher physical solubility of CO₂ and the larger physical mass transfer coefficient in the organic phase. - The CO₂ absorption rate of the organic phase is much higher than that of 30% MEA and 25% AEEA, and even exceeds that of 30% PZ under low - load conditions. - The CO₂ capacity of the aqueous phase is 2.9 times, 1.8 times and 5.3 times that of 30% MEA, 30% PZ and the organic phase respectively. In conclusion, through systematic experimental and theoretical analysis, this paper reveals the superior performance of the 25% AEEA/50% DEEA two - phase solvent in CO₂ capture, providing important scientific basis and technical support for future industrial applications.

CO2 absorption rate in biphasic solvent of aminoethylethanolamine and diethylethanolamine

Deciphering the Transfer Mechanisms for CO2 Absorption into Binary Blended Solutions

Novel Nonaqueous Liquid–Liquid Biphasic Solvent for Energy-Efficient Carbon Dioxide Capture with Low Corrosivity

Selection of Blended Solvents for CO2 Absorption from Coal-Fired Flue Gas. Part 1: Monoethanolamine (Mea)-Based Solvents

Carbon Dioxide Absorption in Aqueous Alkanolamine Blends for Biphasic Solvents Screening and Evaluation

Hybrid Behaviors of CO2 Absorption into Blended DEEA‐based Solution for the Improvement of Capture Performance

Phase Separation Behavior and CO2 Absorption Kinetic Analysis of DETA/DEA/DMAC Biphasic Absorbent

Simulation of a CO_2 Capture System Using Amine Solutions for Selection of Absorbents

Energy-efficient biphasic solvents for industrial CO2 capture: Absorption mechanism and stability characteristics

Energy-efficient non-aqueous biphasic solvent for carbon capture: Absorption mechanism, phase evolution process, and non-corrosiveness

Experimental study on CO2 capture using 2‐(2‐aminoethylamino)ethanol/N,N‐diethyl‐ethanolamine/sulfolane phase‐change absorbents

Novel Biphasic Solvent of AEP/1-propanol/H2O for CO2 Capture with Efficient Regeneration Performance and Low Energy Consumption

Phase Separation Behavior and CO2 2 Absorption Kinetic Analysis of DETA/ DEA/DMAC Biphasic Absorbent

A Novel Phase Change Absorbent for CO2 Capture with Low Viscosity and Effective Absorption–Desorption Properties

Removal of CO2 from Simulated Flue Gas of Power Plants by Membrane-Based Gas Absorption Processes

Research on alkanolamine based physical-chemical solutions as biphasic solvents for CO2 capture

Low-Energy-Consumption CO 2 Capture by Liquid–Solid Phase Change Absorption Using Water-Lean Blends of Amino Acid Salts and 2-Alkoxyethanols

Absorption of carbon dioxide by methyldiethanolamine/piperazine and aqueous ammonia

Reducing the energy penalty and corrosion of carbon dioxide capture using a novel nonaqueous monoethanolamine-based biphasic solvent

Screening of physical-chemical biphasic solvents for CO2 absorption

Kinetics of novel non-corrosive amino functionalized ionic liquid organic solution for CO<sub>2</sub> capture