Abstract:This article proposes a novel ultralow specific ON-resistance (${R}_{ \mathrm{\scriptscriptstyle {ON},sp}}$ ) triple reduced surface field (RESURF) lateral double-diffused MOSFET (LDMOS) with sandwich n-p-n layer. Compared with the conventional triple RESURF LDMOS with n-type top layer (NTTR LDMOS), the new structure is characterized by an additional N-buried layer below the P-buried layer. Due to the introduction of N-buried layer, the concentration of N-top layer will decrease to ensure charge balance, thus making the surface electric field distribution better and the higher additional doping introduced by N-top and N-buried layers can be achieved. The dose and implantation energy of n-p-n layers were simulated and optimized. Furthermore, in order to eliminate the premature avalanche breakdown occurring in the source-centered termination region, substrate termination technology (STT) is applied to avoid the high electric field peaks generated in the curved source region with small curvature radius. But the use of STT makes it easy to breakdown in the transitional region compared with the straight region. Therefore, the transitional region is studied and the crucial parameter $\Delta {L}$ in the layout of transitional region is also optimized. The fabricated device experimentally demonstrated improved performance with low ${R}_{ \mathrm{\scriptscriptstyle {ON},sp}}$ of 78.3 $\text{m}\Omega \cdot $ cm2 and high breakdown voltage (BV) of 795 V, and the experimental ${R}_{ \mathrm{\scriptscriptstyle {ON},sp}}$ is 26.8% lower than that of the conventional triple RESURF LDMOS (CTR LDMOS) and 10% lower than that of the NTTR LDMOS based on ${L}_{d} = 67 \mu \text{m}$ , which can break the silicon limit of CTR and NTTR LDMOS and meet the demand of 700-V high-voltage integrated circuit applications.

A Novel SiC LDMOS with Electric Field Optimization by Step Doping Technology

A Novel RESURF LDMOS with Embedded CB-layer

Ultra-Low On-Resistance SiC LDMOS With Separated-Protected Trench Gates and Trench RESURF Technology

Linearly Graded Doping Drift Region: a Novel Lateral Voltage-Sustaining Layer Used for Improvement of RESURF LDMOS Transistor Performances

A Novel Ultralow R ON,sp Triple RESURF LDMOS With Sandwich n-p-n Layer

Novel Si/SiC Heterojunction Lateral Double-Diffused Metal Oxide Semiconductor With SIPOS Field Plate by Simulation Study

Enhancement of Electrical Safe Operation Area of 60 V nLDMOS by Engineering of Reduced Surface Electrical Field in the Drift Region

A 600V-Class Partial SOI LDMOS with Step-Doped Drift Region

Design and Experimental Demonstration of 4H-SiC Lateral High-Voltage MOSFETs With Double-RESURFs Technology for Power ICs

A High-Performance SiC Super-Junction MOSFET With a Step-Doping Profile

Simulation Study of A 1200V 4H-SiC Lateral MOSFET With Reduced Saturation Current

A New 600V Partial SOI LDMOS with Step-Doped Drift Region

1540 V 21.8mΩ·cm2 4H-SiC lateral MOSFETs with DOUBLE RESURFs for power integration applications

Field Plate-Adaptive Doping: A Novel Surface Electric Field Optimization Technique for SOI LDMOS With Gate Field Plate

Electrical Characterization and Analysis of 4H-Sic Lateral MOSFET (LMOS) for High-Voltage Power Integrated Circuits

A Novel RF LDMOS Fabricated with Standard Foundry Technology

Linearly-Graded Drift Region-Doped (LGDRD) RESURF LDMOS with an Improved Trade-off Between the Breakdown Voltage and On-Resistance

Accumulation-Mode Silicon Carbide Laterally Diffused Metal Oxide Semiconductor with Low Specific on Resistance

Numerical Investigation of Transient Breakdown Voltage Enhancement in SOI LDMOS by Using a Step P-Type Doping Buried Layer

RESURF Ga$_{2}$O$_{3}$-on-SiC Field Effect Transistors for Enhanced Breakdown Voltage

A novel double-gate trench SOI LDMOS with double-dielectric material by TCAD Simulation Study