Abstract:An experimental study has been carried out in a rectangular mini-channel to investigate the two-phase flow instabilities of a forced flow at low pressure. The inlet mass flux is gradually reduced by decreasing the rotational speed of the primary pump until the flow becomes unstable, while maintaining all other thermal parameters including system pressure, inlet temperature and heat flux unchanged. Three types of flow instabilities, density wave oscillation (DWO), pressure drop oscillation (PDO) and Ledinegg instability (LED) are identified during the experiment. The onset of flow instability (OFI) is determined by the demand curves and shows good agreement with Roach and Stoddard's correlations. The OFI is consistent with the boiling incipience and saturated condition. The stability map is obtained on the plane of subcooling number (N-sub) and phase change number (N-pCh). DWO and PDO occur at the region between the outlet steam quality x(e) = -0.001 and x(e) = -0.012, while the LED region becomes narrow with increasing subcooling. Finally, the mechanisms of flow instabilities in our experiment are analyzed. The results show that the PDO observed in this work is not accompanied by CHF (dryout) which is supposed to be the most common phenomenon of flow instabilities in mini-/micro-channels. DWO occurrence is determined by the relation between external forces (gravitational force and pump driving force) and surface tension. As the external forces are dominant, Type-I DWO at low outlet steam quality (DWOI) occurs. However, with reduction of the inlet mass flux, the surface tension begins to play a dominant role. Thus Type-II DWO at high outlet quality (DWOII), which is expected in most ordinarily sized channels, has not been observed during this work. (C) 2016 Elsevier Ltd. All rights reserved.

EXPERIMENTAL INVESTIGATION AND FLOW VISUALIZATION OF THE TWO-PHASE FLOW INSTABILITY AT LOW VAPOR QUALITY IN A VERTICAL NARROW CHANNEL

Investigation of two phase flow instability in a narrow channel

Effects of parameters on the two phase flow instability in a microchannel

Two-Phase Flow Instability of Boiling in A Double Microchannel System at High Heating Powers

ICONE23-1676 EXPERIMENTAL INVESTIGATION ON FLOW INSTABILITY OF FORCED CIRCULATION IN A VERTICAL MINI-RECTANGULAR CHANNEL

Experimental Study of Flow Boiling Instabilities in Horizontal Tubes under Gas–liquid Stratification Condition: Effects of Heat Flux and Inlet Subcooling Degree

EXPERIMENTAL STUDY ON FLOW INSTABILITY OF NATURAL CIRCULATION IN A VERTICAL RECTANGULAR MINI-CHANNEL UNDER ROLLING MOTION

Experimental investigation on the convective boiling flow instabilities of steam/water two phase flow in horizontal helically coiled tube

Two-phase Flow Instabilities of Forced Circulation at Low Pressure in a Rectangular Mini-Channel

Experimental Investigation into Unstable Two Phase Flow Phenomena During Flow Boiling in Multi-Microchannels

Investigating Flow Instability Mode and Characteristics in a Microchannel Evaporator

Experimental Study of Natural Circulation Flow Instability Induced by Flow Boiling and Loop Circulation

Experiment on Density Wave Oscillation Instability of Two-Phase Flow in Low Mass Velocity Parallel Vertical Rifled Tubes

Experimental Study on the Pressure Drop Oscillation Characteristics of the Flow Boiling Instability with FC-72 in Parallel Rectangle Microchannels

Experimental Study on Natural Circulation Flow Instability in Parallel Boiling Channels under Low Pressure

UNSTEADY FLOW PHENOMENON IN A HEATED MICROCHANNEL AT HIGH HEAT FLUXES

Experimental study on turbulent characteristics of dispersed bubbly flow in a narrow rectangular channel by two-phase PIV

Bubble Behaviors under Subcooled Flow Boiling Instability in Narrow Channel

Experimental Investigations on Flow Characteristics of Two Parallel Channels in A Forced Circulation Loop with Supercritical Water

EXPERIMENTAL STUDY ON TWO-PHASE NATURAL CIRCULATION FLOW INSTABILITY IN ROD BUNDLE CHANNEL UNDER LOW PRESSURE CONDITION

Experimental Investigation on Flow Oscillation of Boiling Two-Phase Flow in a Single Rod Channel