Abstract:Al2O3, as one of the gate dielectric materials for thin film transistors (TFTs), has been extensively investigated because of its large bandgap, high breakdown field, and good thermal stability. However, the further development of Al2O3 thin films is limited by the presence of defects such as oxygen vacancies, self-interstitial atoms, or impurity elements. To overcome this obstacle, we have developed a novel method for fabricating Al2O3 thin films by using the atomic layer deposition (ALD) technique. This method replaces the conventional Trimethylaluminium (TMA)/H2O cycles with TMA/TMA/H2O/H2O cycles (referred to as ‘double cycles’), to deposit the Al2O3. The 5-nm ultrathin Al2O3 film showed a high areal capacitance of 660 nF/cm2 at 20 Hz, and a relatively low current density of 10−8 A/cm2 at 1 MV/cm. InGaZnO (IGZO) TFTs with ultrathin Al2O3 gate dielectric grown by double cycles exhibited outstanding performances, such as a near theoretical limit subthreshold swing (SS) of 70 mV/decade, a higher on/off current ratio $(I_{\mathrm{ on}} / I_{\mathrm{ off}}$ ) of 106, an increased field-effect mobility ( $\mu $ ) of 6.5 cm2/Vs, a lower threshold voltage $(V_{\mathrm{ th}})$ of 0.2 V, and a low operating voltage of 3 V. These results are superior to the IGZO TFTs with Al2O3 dielectrics deposited using the single TMA/H2O cycle. Therefore, the implementation of ‘double cycles’ in the fabrication of dielectrics through ALD demonstrates considerable potential for future application in low-power electronic devices.

Approaching Subthreshold-Swing Limit for Thin-Film Transistors by Using a Giant-Dielectric-constant Gate Dielectric

Fully solution-induced high performance indium oxide thin film transistors with ZrOx high-k gate dielectrics

59.9 mV·dec Subthreshold Swing Achieved in Zinc Tin Oxide TFTs With In Situ Atomic Layer Deposited AlO Gate Insulator

Low-Voltage Depletion-Mode Indium-Tin-Oxide Thin-Film Transistors Gated by Ba 0.4 Sr 0.6 TiO 3 Dielectric

Indium-Tin-Oxide Transistors with One Nanometer Thick Channel and Ferroelectric Gating

Microporous SiO2 with Huge Electric-Double-layer Capacitance for Low-Voltage Indium Tin Oxide Thin-Film Transistors

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al<sub>2</sub>O<sub>3</sub> Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

Low-Voltage High-Stability Indium–Zinc Oxide Thin-Film Transistor Gated by Anodized Neodymium-Doped Aluminum

Low-Voltage High-Stability InZnO Thin-Film Transistor Using Ultra-Thin Solution-Processed ZrO Dielectric

Low-Temperature Solution-Processed Zirconium Oxide Gate Insulators for Thin-Film Transistors

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al₂O₃ Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al2O3 Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

Ultralow-Voltage Transparent Electric-Double-Layer Thin-Film Transistors Processed at Room-Temperature

Solution-Processed Zirconium Oxide Gate Insulators for Top Gate and Low Operating Voltage Thin-Film Transistor

High-Performance Amorphous InGaZnO Thin-Film Transistor Gated by HfAlOₓ Dielectric with Ultralow Subthreshold Swing

Low-voltage, Solution-Processed InZnO Thin-Film Transistors with Enhanced Performance Achieved by Bilayer Gate Dielectrics

Chitosan-Gated Low-Voltage Transparent Indium-Free Aluminum-Doped Zinc Oxide Thin-Film Transistors

Effect of Gate Insulator Thickness on Device Performance of Ingazno Thin-Film Transistors

A Sputtered Silicon Oxide Electrolyte for High-Performance Thin-Film Transistors

High Performance Aluminum-Doped Zno Thin Film Transistors with High-K Gate Dielectrics Fabricated at Low Temperature

High Performance (vth ~ 0 V, SS ~ 69 Mv/dec, IOn/IOff ~ 1010) Thin-Film Transistors Using Ultrathin Indium Oxide Channel and SiO2 Passivation