Abstract:Al2O3, as one of the gate dielectric materials for thin film transistors (TFTs), has been extensively investigated because of its large bandgap, high breakdown field, and good thermal stability. However, the further development of Al2O3 thin films is limited by the presence of defects such as oxygen vacancies, self-interstitial atoms, or impurity elements. To overcome this obstacle, we have developed a novel method for fabricating Al2O3 thin films by using the atomic layer deposition (ALD) technique. This method replaces the conventional Trimethylaluminium (TMA)/H2O cycles with TMA/TMA/H2O/H2O cycles (referred to as 'double cycles'), to deposit the Al2O3 . The 5-nm ultrathin Al2O3 film showed a high areal capacitance of 660 nF/cm(2) at 20 Hz, and a relatively low current density of 10(-8) A/cm(2) at 1 MV/cm. InGaZnO (IGZO) TFTs with ultrathin Al2O3 gate dielectric grown by double cycles exhibited outstanding performances, such as a near theoretical limit subthreshold swing (SS) of 70 mV/decade, a higher on/off current ratio (I-on/I-off) of 106, an increased field-effect mobility (mu) of 6.5 cm(2)/Vs, a lower threshold voltage (V-th) of 0.2 V, and a low operating voltage of 3 V. These results are superior to the IGZO TFTs with Al2O3 dielectrics deposited using the single TMA/H2O cycle. Therefore, the implementation of 'double cycles' in the fabrication of dielectrics through ALD demonstrates considerable potential for future application in low-power electronic devices.

Ultralow-Voltage Transparent Electric-Double-Layer Thin-Film Transistors Processed at Room-Temperature

Low-voltage Transparent Electric-Double-layer ZnO-based Thin-Film Transistors for Portable Transparent Electronics

Eco-Friendly, Water-Induced In2O3 Thin Films for High-Performance Thin-Film Transistors and Inverters

Low-voltage ZnO thin-film transistors operating at 2.0 V gated with mesoporous SiO2 dielectric processed at room-temperature

Microporous SiO2 with Huge Electric-Double-layer Capacitance for Low-Voltage Indium Tin Oxide Thin-Film Transistors

Self-Assembled Ultralow-Voltage Flexible Transparent Thin-Film Transistors Gated By Sio2-Based Solid Electrolyte

One-Volt Oxide Thin-Film Transistors on Paper Substrates Gated by $\hbox{sio}_{2}$ -Based Solid Electrolyte with Controllable Operation Modes

Electrical Properties of Wide Bandgap ZnMgO and Fabrication of Transparent Thin Film Transistors

Low-voltage Zinc Oxide Thin-Film Transistors with Solution-Processed Channel and Dielectric Layers below 150 °C

Ultralow-Voltage Transparent $\hbox{in}_{2} \hbox{o}_{3}$ Nanowire Electric-Double-Layer Transistors

Low-Voltage Transparent Indium–Zinc–Oxide Coplanar Homojunction TFTs Self-Assembled on Inorganic Proton Conductors

Transparent Thin-Film Transistors Using ZnMgO as Dielectrics and Channel

Amorphous IZO-based transparent thin film transistors

Fabrication and performance of indium oxide based transparent thin film transistors

Ultraviolet Light-Densified Oxide-Organic Self-Assembled Dielectrics: Processing Thin-Film Transistors at Room Temperature

Low-Temperature Fabrication of Fully Transparent Igzo Thin Film Transistors on Glass Substrate

Chemical and Electrical Properties of Low-Temperature Solution-Processed In–Ga–Zn-O Thin-Film Transistors

Self-Assembled Ultralow-Voltage Flexible Transparent Thin-Film Transistors Gated by $\Hbox{sio}_{2}$-Based Solid Electrolyte

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al<sub>2</sub>O<sub>3</sub> Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

A Sputtered Silicon Oxide Electrolyte for High-Performance Thin-Film Transistors

Low-Temperature Solution-Processed Bilayer Ingazno/In 2O 3 Thin Film Transistors Based on Lightwave Annealing