Abstract:Reactivity loss (deactivation) of char in pulverized coal firing boiler were proved in previous research, with different explanations including decreasing specific surface area, structural ordering of carbon, residual inert component and catalytic effect of mineral matter, etc. The main reasons, accepted gradually, are the ordering of turbostratic carbon structure and the loss of catalytic effect of mineral matter containing Ca, Na, K, Fe or other elements. After confirming the char deactivation under circulating fluidized bed combustion (CFBC) temperature condition, the present paper is focused on the catalytic effect of mineral matter on char reactivity and three coal samples were studied experimentally. Interferences to experimental results caused by effects of coal inhomogeneity, particle size and volatile release on char properties have been greatly reduced by special methods. Acid treatment method was used to remove the mineral matter in coal samples. The reactivity of different chars produced by treated and un-treated vitrinite-rich coal samples were measured and compared to determine the catalytic effects and influence factors. Experimental results show that catalytic effect decreases rapidly when temperature increases, and nearly disappears close to 1200degreesC. Char deactivation has been found to be due to the combined effect of the ordering of turbostratic carbon structure and the loss of catalytic effect of minerals under CFBC condition. But the different catalytic effects are observed for different coals. Different from sample YX, sample DT and JJ have little catalytic effect for covering the surface of coal particles and restraining the diffusion of oxygen.

Regeneration of Deactivated Circulating Ash Using Coking in a CFBB

INVESTIGATION OF CATALYTIC DEACTIVITY AND ACTIVITY REGENERATION OF CIRCULATING ASH OF CFBB IN TAR CRACKING REACTIONS

Effect of Cracking Reactions of Tar Components on Activity of CFBB Circulating Ash

Experimental investigation on catalytic cracking reactions of main components of tar over circulating ash of CFBB

Investigation of the deactivaty of a kind of circulating ash when the tar cracking over it

The Activity Regeneration of Deactivate Calcium Oxide With Coking

Deactivation and Burning Regeneration of Coked Acid Catalysts in Catalytic Cracking Process of Biomass Tar

Secondary Catalytic Reaction of Circulating Ash on the Primary Volatiles of Coal Pyrolysis

CFD Modelling of the Co-Gasification of Biomass and Coal Particles in Fluidised Beds

Efficient decarburization modification of coal gasification fine ash by microwave field activation

Effect of Steam on the Tar Reforming during Circulating Fluidized Bed Char Gasification

Catalytic Effect Of Mineral Matter On Char Reactivity Under Cfbc Temperature Condition

Carbon Formation Mechanism in Fly Ash of Circulating Fluidized Bed Boilers

Study On The Deactivation And Activity Regeneration Of Catalyst In Biomass Tar Cracking

Experimental Study on the Improvement of Char Physicochemical Properties and Reactivity by Activation Process in CFB

Characteristics of Coal Partial Gasification on A Circulating Fluidized Bed Reactor

Experimental Study on Combining Partial Gasification With Air on a Fluidized Bed at Atmospheric Pressure and Semi-coke Combustion

Experimental study on thermal modification characteristics of entrained-flow gasified fine ash using circulating fluidized bed

Coal Combustion Efficiency in Circulation Fluidized Bed

Pilot Development of Polygeneration Process of Circulating Fluidized Bed Combustion Combined with Coal Pyrolysis

Development of gas, power and tar co-generation system with circulating fluidized bed technology