Abstract:Positive-pressure fluidized bed technology utilizes the pressure generated by biomass gasification to facilitate further combustion within the furnace. This technique addresses the safety risks associated with external pressure in fluidizing medium and high-temperature situations and reduces equipment investment and operating expenses. However, research on the effects of the positive-pressure process in fluidized beds on gasification coupled with coal-fired power generation systems is scarce. To fill this research gap, extensive experimentation and Aspen Plus simulation were conducted to investigate the impact of equivalence ratio (ER), gasification pressure, and gasification temperature on the gasification performance. A 660 MW coal-fired boiler model was established to reveal the coupling effect on flue gas temperature and thermal efficiency by gasification from a positive-pressure fluidized bed on the boiler, and its accuracy was proved by comparing the actual boiler design parameters. The power generation cost of the positive-pressure gasification coupled coal-fired power generation system is calculated with the established model. The results indicate that an increase in gasification pressure from 4000Pa to 8000Pa resulted in no significant change in the operating indicators of the boiler, with the tail gas temperature near 132 degrees C and a boiler thermal efficiency of 92.68 %. Gas yield, carbon conversion rate, and gasification efficiency were positively correlated with gasification temperature and ER. However, the heat value of combustible gas increased with the gasification temperature and decreased with an increase in ER. With the rise of the biomass gas blending ratio, the power generation cost of the unit gradually decreases. Respectively, the positive -pressure would lower the power generation costs of a 660 MW coal-fired boiler by 5.76 x 105$/ year. This study demonstrates that positive-pressure fluidized bed gasification may retain high gas yields and efficiency, significantly lowering equipment investment and operating expenses, as a very efficient energy-saving and carbon-reduction technique.

Experimental Study on Combining Partial Gasification With Air on a Fluidized Bed at Atmospheric Pressure and Semi-coke Combustion

Examination of Industrial Demonstration Unit of Coal Gasification for Pulverized Coal with Ash Agglomeration Technique

Development of Coal Partial Gasification and Combustion System

TEST STUDY ON CO-GENERATION SCHEME WITH COAL PYROLYSIS COMBUSTION

Characteristics of Coal Partial Gasification on A Circulating Fluidized Bed Reactor

EXPERIMENTAL STUDY ON GASIFICATION IN DUAL FLUIDIZED BEDS

Experimental Study on Coal Partial Gasification Coproducing Char, Tar, and Gas

Characteristics of Coal Partial Gasification Experiments on a Circulating Fluidized Bed Reactor under CO2-O-2 Atmosphere

Co-gasification of Acid Hydrolysis Residues and Sewage Sludge in a Downdraft Fixed Gasifier with CaO As an In-Bed Additive

Effect of Air Equivalence Ratio on the Characteristics of Biomass Partial Gasification for Syngas and Biochar Co-Production in the Fluidized Bed

STUDY ON PARTIAL GASIFICATION OF COAL WITH AIR AND STEAM

CFD simulation of air-blown coal gasification in a fluidized bed reactor with continuous feedstock

Experimental Investigation on Co-firing of Coal and Refuse-derived Fuel in a Pilot-scale Circulating Fluidized Bed Combustor

A pilot scale test on the fluidized melting combustion of coal gasification fine slag

Coal Char Gasification on A Circulating Fluidized Bed for Hydrogen Generation: Experiments and Simulation

Experimental and Simulation Study on Coal-fired Power Generation Coupling with Fluidized Bed Biomass Gasification

Experimental Study on 75 T/h Circulating Fluidized Bed Poly-generation System

Research on Coal Staged Conversion Poly-Generation System Based on Fluidized Bed

Multiphase flow and reactor optimization of a 1MWth pilot-scale circulating fluidized bed for coal staged conversion

Numerical and experimental assessment of parametric effect on steam-carbon dioxide co-gasification of sewage sludge and coal in an updraft reactor

Pilot Development of Polygeneration Process of Circulating Fluidized Bed Combustion Combined with Coal Pyrolysis