Abstract:The morphology of zinc electrodeposition was investigated from alkaline zincate solutions on single grains of known orientation in polycrystalline zinc electrodes under potentiostatic control. The effect of overpotential, solution composition, and substrate orientation were examined. The deposition morphology was observed with a scanning electron microscope. It was found possible to disrupt the deposition repeatedly for microscopic observation, and then continue deposition. At low overpotential (50 mV) epitaxial layer type growth was observed; the width of the macrosteps increased linearly with time. A theory explaining the linear step widening is proposed, which can also account for the observed effect of substrate orientation. At 100 mV, “boulders” were observed, not all of which were epitaxial with the substrate. They are suggested to be originated by nucleation. The boulder density per cm2 is first sharply increasing, then slowly decreasing with time. A statistical calculation for this is given, based on the model that large boulders consume the smaller ones. With further deposition a small fraction (ca. 0.1%) of the boulders develop into dendrites, their number being limited by the available total current. Experiments were carried out to differentiate between over‐potential and current control of morphology; overpotential was found to be the critical variable.

Zn Electrodeposition On Single-Crystal Gan(0001) Surface: Nucleation And Growth Mechanism

Electrochemical Deposition of Copper on Single-Crystal Gallium Nitride(0001) Electrode: Nucleation and Growth Mechanism

Epitaxial Deposition of Zn (0 0 2) for Stable Zinc Metal Anodes

Epitaxial Deposition of Zn (002) for Stable Zinc Metal Anodes

On the Morphology of Zinc Electrodeposition from Alkaline Solutions

Electrochemical Fabrication and Interfacial Charge-Transfer Process of Ni/GaN(0001) Electrodes.

Toward Planar and Dendrite‐Free Zn Electrodepositions by Regulating Sn‐Crystal Textured Surface

Mxene and GaIn Alloy Nanostructures Regulate Zn Surface Ion Deposition for High-Performance Zinc-Ion Battery

The Role of Zinc Pre-Exposure in Low-Defect Znse Growth on As-Stabilized Gaas (001)

Growth of Znse Films on Gaas by Ionized Cluster Beam Epitaxy

Heteroepitaxial Growth of Cubic Gan on GaAs(100) by Reactive Nitrogen Source

Role of Gallium Wetting Layer in High-Quality Zno Growth on Sapphire(0001) Substrates

Optimization of Electrochemical Aspects for Epitaxial Depositing Nanoscale ZnSe Thin Films

Heteroepitaxial Growth of ZnO Nanorod Arrays on GaAs (111) Substrates by Electrochemical Deposition

Growth Of Single- And Bilayer Zno On Au(111) And Interaction With Copper

Molecular-beam-epitaxy Growth of GaN on GaAs(100) by Using Reactive Nitrogen Source

Nucleation and Growth of Bismuth Electrodeposition from Alkaline Electrolyte

Spontaneous Ga Incorporation in Zno Nanowires Epitaxially Grown on Gan Substrate

Clean and As-Covered Zinc-Blende GaN (001) Surfaces: Novel Surface Structures and Surfactant Behavior

First-principle study on GaN(100) surface structure

Investigation Of Preparation And Properties Of Epitaxial Growth Gan Film On Si(111) Substrate