Abstract:Al2O3, as one of the gate dielectric materials for thin film transistors (TFTs), has been extensively investigated because of its large bandgap, high breakdown field, and good thermal stability. However, the further development of Al2O3 thin films is limited by the presence of defects such as oxygen vacancies, self-interstitial atoms, or impurity elements. To overcome this obstacle, we have developed a novel method for fabricating Al2O3 thin films by using the atomic layer deposition (ALD) technique. This method replaces the conventional Trimethylaluminium (TMA)/H2O cycles with TMA/TMA/H2O/H2O cycles (referred to as ‘double cycles’), to deposit the Al2O3. The 5-nm ultrathin Al2O3 film showed a high areal capacitance of 660 nF/cm2 at 20 Hz, and a relatively low current density of 10−8 A/cm2 at 1 MV/cm. InGaZnO (IGZO) TFTs with ultrathin Al2O3 gate dielectric grown by double cycles exhibited outstanding performances, such as a near theoretical limit subthreshold swing (SS) of 70 mV/decade, a higher on/off current ratio $(I_{\mathrm{ on}} / I_{\mathrm{ off}}$ ) of 106, an increased field-effect mobility ( $\mu $ ) of 6.5 cm2/Vs, a lower threshold voltage $(V_{\mathrm{ th}})$ of 0.2 V, and a low operating voltage of 3 V. These results are superior to the IGZO TFTs with Al2O3 dielectrics deposited using the single TMA/H2O cycle. Therefore, the implementation of ‘double cycles’ in the fabrication of dielectrics through ALD demonstrates considerable potential for future application in low-power electronic devices.

High-performance Ti-doped zinc oxide TFTs with double-layer gate dielectric fabricated at low temperature

High-Performance Polycrystalline Sige Thin-Film Transistors Using Al2o3 Gate Insulators

High Performance Aluminum-Doped Zno Thin Film Transistors with High-K Gate Dielectrics Fabricated at Low Temperature

High-performance Si-doped ZnO Thin-film Transistors Fabricated on Flexible Plastic Substrate at Low Temperature

P‐15: High‐Performance Fully Transparent Hafnium‐Doped Zinc Oxide TFTs Fabricated at Low Temperature

Performance Enhancement of Fully Transparent Tin-Doped Zinc Oxide Thin-Film Transistors Fabricated by Sputtering at Low Temperature

High-performance ZnO Thin-Film Transistors Prepared by Atomic Layer Deposition at Low Temperature

High-performance transparent AZO TFTs fabricated on glass substrate

Effects of various oxygen partial pressures on Ti-doped ZnO thin film transistors fabricated on flexible plastic substrate

Low-Temperature Solution-Processed Zirconium Oxide Gate Insulators for Thin-Film Transistors

Solution-Processed Zinc Oxide Thin-Film Transistors with a Low-Temperature Polymer Passivation Layer

Low-Temperature ZnO TFTs Fabricated by Reactive Sputtering of Metallic Zinc Target

P‐1.11: High‐mobility ZnO thin‐film transistors with HfO<sub>2</sub>/Al<sub>2</sub>O<sub>3</sub> bilayer dielectric

Low-voltage Zinc Oxide Thin-Film Transistors with Solution-Processed Channel and Dielectric Layers below 150 °C

High-Performance ZnO Thin-Film Transistors Prepared by Atomic Layer Deposition

Fabrication optimization to improve performance of gallium-doped zinc oxide thin film transistors

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al2O3 Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

High-performance dual-layer channel ITO/TZO TFTs fabricated on glass substrate

Effects of Substrate Temperature on Performance of Calcium-Doped Zinc Oxide Tfts

High-Performance of InGaZnO TFTs With an Ultrathin 5-nm Al₂O₃ Gate Dielectric Enabled by a Novel Atomic Layer Deposition Method

High-Performance Thin-Film Transistors with ZnO/Al2O3 Superlattice Channel Fabricated by Atomic Layer Deposition