Abstract:Fabrication of nano-crystalline thin film solar cell by co-sputtering of silicon and aluminum, and metal induced crystallization is reported in this paper. After a brief introduction on magnetron sputtering and aluminum induced crystallization techniques, it discusses the drawbacks of "aluminum induced layer exchange" concept as the common method for fabricating poly-Si thin films; and proposes Si-Al co-sputtering as a simple alternative fabrication method. Then a three-steps process is introduced for the fabrication of "Al electrode/n-Si wafer/p-Si thin film/Al electrode" solar cell. Material and electrical characterizations of the fabricated p-Si thin films are done by Raman spectroscopy, X-ray diffraction, optical microscopy, scanning electron microscopy and Hall Effect measurement to study the crystallization ratio, grain size, morphology, carrier density and mobility of the prepared films, respectively. The best fabricated samples show a crystallization ratio of 88% and the largest grain size of 68 nm. The hole concentration in the films is in the order of 10(18) to 10(19) cm(-1) with a maximum mobility value of 17 cm(2)/V s. Then, photovoltaic properties of the fabricated solar cells are determined by under dark and illumination J-V curves, and external quantum efficiency measurements. Dark J-V curve of the best sample represents an ideality factor of 1.39, rectification ratio of 1993 at 1 V and reverse saturation current density of 62.1 nA/cm(2) which confirms the formation of a good p-n junction. The illuminated J-V curve under AM1.5G conditions exhibits a photovoltaic conversion efficiency of 6.02% for the best sample, with a short circuit current density of 24.9 mA/cm(2) and open circuit voltage of 456 mV. The external quantum efficiency of this sample reaches to more than 59% at the wavelength of 700 nm. Finally, a simple model is proposed to describe the formation of nano-crystalline Si thin film, deposited by Si-Al co-sputtering, during the thermal annealing.

Crystallization of Sputtered Amorphous Silicon Induced by Silver–copper Alloy with High Crystalline Volumeratio

Nickel Induced Crystallization of Amorphous Silicon Thin Films

Novel Sandwich Structure for Aluminum Induced Crystallization of Amorphous Silicon Thin Films at Low Temperature

Super large grain size of poly-Si obtained by using the solid-phase crystallization method

Copper-Induced Crystallization of Sputtered Silicon on Zno:Al Substrate and the Textured Interface for Light Trapping

Metal induced crystallization of silicon film via direct forming of discontinuous copper film

Epitaxil Electrodeposition Of A Crystalline Metal Oxide Onto Single-Crystalline Silicon

Preparation of Polycrystalline Silicon of 100μm Size Large Grain Thin Films by Metal Induced Crystallization

Influence of Precursor A-Si:H Dehydrogenation on the Aluminum Induced Crystallization Process

Mechanism of Silver/glass Interaction in the Metallization of Crystalline Silicon Solar Cells

Preparation of High Quality Polycrystalline Silicon Thin Films by Aluminum-Induced Crystallization

Epitaxial Electrodeposition of a Crystalline Metal Oxide onto Single-Crystalline Silicon

Design of advanced porous silver powder with high-sintering activity to improve silicon solar cells

Differently shaped Ag crystallites and four current transport paths at sintered Ag/Si interface of crystalline silicon solar cells

Microstructure and Conductivity of Large Area Nanocrystalline Silicon Films Grown by Specially Designed Thermal-Assisted Chemical Vapor Deposition

Ohimc Contact Formation Mechanism of Silver–Aluminum Paste Metallization on the p+ Emitter of n-Type Crystalline Silicon Solar Cells

Nano-crystalline Thin Films Fabricated by Si-Al Co-Sputtering and Metal Induced Crystallization for Photovoltaic Applications

Impact of Alumina Coatings on Aluminum-Induced Crystallization of Polycrystalline Silicon Films

Effect of oxide layer on Al-induced crystallization of amorphous Si1−xGex thin films

Fractal growth of amorphous silicon crystallization induced by aluminum

The Crystallization of Cr–Si–Ni–Al Amorphous Films—nucleation and Growth of Intermetallic Phase Cr(Al,Si)2