Abstract:Phase equilibria in the Al2O3–Ta2O5 system have been studied by means of CO2 laser heater, high‐speed pyrometer, X‐ray powder diffraction, and scanning electron microscopy. The liquidus and invariant reaction temperatures in the whole composition region were measured by cooling trace tests. The monotectic reaction of Liquid 1→Liquid 2 + Al2O3 was determined to be at about 1547°C, but the typical microstructures for the miscibility gap were not directly observed in our experiments. The tetragonal AlTaO4 phases formed from as‐cast samples were found to congruently melt at 1669°C, and they could maintain stability during the cooling process but would gradually transform into orthorhombic and monoclinic polymorphs after heat treatment. Two eutectic reactions of Liquid → Al2O3 + T‐AlTaO4 and Liquid → T‐AlTaO4 + β‐Ta2O5 were measured to be at 1447°C and 36.7 mol%Ta2O5 and 1513°C and 63.5 mol% Ta2O5, respectively. Due to the undercooling effect, the invariant reaction temperatures determined by this work might be preliminary and need to be verified by more accurate methods. Our experiments confirmed that doping Al2O3 in Ta2O5 phases could improve phase stability of β‐Ta2O5. Finally, thermodynamic optimization of the Al2O3–Ta2O5 system was performed based on the obtained experimental data by means of the CALPHAD method. The self‐consistent thermodynamic parameters are helpful in further efforts for construction of Al2O3–Ta2O5‐based multicomponent thermodynamic database and the development of alumina–tantala‐based materials.

Phase Equilibria of the Co–Ta–Ti System at 950°C

Phase diagram of the Co-Cu-Ti system at 850°C

Phase equilibria in Ni–Ti–Ta ternary system

Experimental Investigation of Phase Equilibria in the Co-Ta-Si Ternary System

Isothermal Section at 950°C of the Co–Nb–Ti System

Phase Equilibria of the Fe–Nb–Ti System at 900 °C

Phase Equilibria of the Co—Ni—Ta System at 1100 °C.

Experimental Investigation and Thermodynamic Description of the Fe–Ta–Ti System

Study on the phase equilibria of the Ti–Ni–Nb ternary system at 900°C

The stability and homogeneity range of the TCP phases in the Co-Fe-Ta system

Experimental Investigation of Phase Equilibria in the Fe-Nb-Ta System

Phase equilibria in Co-Ti-Re ternary system

Experimental Study on Phase Relationships in the Co-rich Portion of the Co–Ti–Zr System

Study on the phase equilibria of the Ti-Ni-Nb ternary system at 900 degrees C

Stability of the metastable phases in the Co-Ta system studied by ab initio and thermodynamic calculations together with ion-beam-mixing experiment

Phase Constituents in Ni–Al–Co–Ti Quaternary Alloys

Phase equilibrium investigations of the Al2O3–Ta2O5 system: New experiments and thermodynamic modeling

Thermodynamic Description and Simulation of Solidification Microstructure in the Co-Ti System

Experimental determination of isothermal sections for the Co-rich corner of the Co-Cr-Ti system at 800 and 900 °C

Phase relationships and transformations in the ternary aluminum—titanium—tantalum system

Experimental Investigation on Isothermal Sections at 1273 and 1473 K in the Co–Ti–W System