Abstract:This study reported the fabrication of a large area of micro/nano structures with different morphologies and sizes by the deposition of ablated material and melting of material on silicon through a line-shaped femtosecond laser beam irradiation. The evolution of micro/nano structures on the silicon surface was demonstrated with the laser fluence of 0.64 J/cm(2). It was found that the melting of material was responsible for the formation of the micro-protrusions from laser-induced periodic surface structures (LIPSSs). Additionally, the deposition fell on the surface of the micro-protrusions in oblique incidence way, causing LIPSSs obscure and even invisible. As a consequence, those micro-protrusions gradually evolved into the micro-spikes with the ladder-like surface. Then, various laser fluences were applied to regulate the deposition and melting behaviors of silicon, to obtain the micro/nano structures with different morphologies and sizes. The formation mechanism of these micro/nano structures was analyzed. On this basis, the optical properties test showed that best anti-reflectivity was referred to the sample full of micro-spikes with the ladder-like surface, and the average reflectance has decreased from similar to 38.17% of the planar silicon to similar to 4.75% in the waveband between 300 and 1000 nm. (C) 2018 Elsevier B.V. All rights reserved.

Nanobump Arrays Fabricated by Laser Irradiation of Polystyrene Particle Layers on Silicon

Laser microstructuring of Si surfaces for low-threshold field-electron emission

Laser Pulse Number Dependent Nanostructure Evolution by Illuminating Self-Assembled Microsphere Array

Nano-Patterning by Pulsed Laser Irradiation in Near Field

Generation of periodic nanobumps through a double-scan method with femtosecond lasers

Fabrication of large-area nickel nanobump arrays

Formation of Polymer Micro-Bump with Laser Rear-Side Irradiation and Sacrificial Layer

Formation of a Dense Nanocrystalline Si Array on an Insulating Layer by Laser Irradiation of Ultrathin Amorphous Si Films

Parallel Nanostructuring of Gesbte Film with Particle Mask

Formation of Periodical Sub-Micron Sized Structures on Silicon by Interfered Nanosecond Laser Pulses

FABRICATION OF SILICON NANOARRAYS BY DIRECT NANOSPHERE LITHOGRAPHY

Nanopatterning of the dielectric surface by a pair of femtosecond laser pulses of different colors through a monolayer of microspheres

Formation of Array Microstructures on Silicon by Multibeam Interfered Femtosecond Laser Pulses

An approach to obtain single layer of nanostructured Si by laser irradiation on ultrathin amorphous Si films

High Density Si Nanodots-Fabrication and Properties

Fabrication of microstructures by picosecond laser

Deep Investigation of Two-Dimensional Structure Arrays Formed on Si Surface

Direct Fabrication of Sub-micron Sized Mirco-structure by Interfering Nanosecond Laser Beams

Deposition and Melting Behaviors for Formation of Micro/nano Structures from Nanostructures with Femtosecond Pulses

Control of deposition channels in nanosphere templates for high-density nanodot array production

Surface Plasmons Excited from Close-Packed Nanoring Tube Arrays Produced by Nanosphere Lithography