Abstract:Two kinds of Zr-rich Zr-aluminate films for high-kappa gate dielectric applications with the nominal composition of (ZrO2)(0.8)(Al2O3)(0.2) and (ZrO2)(0.9)(Al2O3)(0.1), were deposited on n-type silicon wafer by pulsed laser deposition (PLD) technique at different deposition conditions. X-ray diffraction (XRD) reveals that the (ZrO2)(0.8)(Al2O3)(0.2) film could remain amorphous after being rapid thermal annealed (RTA) at the temperature above 800 degrees C, while the other one displays some crystalline peaks at 700 degrees C. The energy gap calculated from optical transmittance spectrum of (ZrO2)(0.8)(Al2O3)(0.2) film on quartz is about 6.0 eV. Sputtering depth profile of X-ray photoelectron spectroscopy and Auger electron spectroscopy indicate that a Zr-Si-O interfacial layer was formed at the near surface of the silicon substrate. The dielectric constant of the (ZrO2)(0.8)(Al2O3)(0.2) film has been determined to be 22.1 by measuring a Pt/(ZrO2)(0.8)(Al2O3)(0.2)/Pt MIM structure. An EOT of 1.76 nm with a leakage current density of 51.5 mA/cm(2) at 1 V gate voltage for the film deposited in N-2 were obtained. Two different pre-treatments of Si substrates prior to depositions were also carried out and compared. The results indicate that a surface-nitrided Si substrate can lead to a lower leakage current density. The amorphous Zr-rich Zr-aluminate films fabricated by PLD have promising structure and dielectric properties required for it candidate material for high-kappa Late dielectric applications. (c) 2005 Elsevier B.V. All rights reserved.

Structural and Electrical Characteristics of Amorphous ErAlO Gate Dielectric Films

Structural Characteristics of Amorphous Er<SUB>2</SUB>O<SUB>3</SUB> Films Grown on Si (001) by Reactive Evaporation: Structural Characteristics of Amorphous Er<SUB>2</SUB>O<SUB>3</SUB> Films Grown on Si (001) by Reactive Evaporation

Structure and electrical characterization of amorphous ErSiO films deposited by rf magnetron sputtering on Si (001)

Structural And Electrical Characterization Of Ultrathin Er2o3 Films Grown On Si(001) By Reactive Evaporation

Annealing Effects on the Structure and Electrical Characteristics of Amorphous Er 2 O 3 Films

The thermal stability and electrical properties of LaErO<sub>3</sub>films as high-<i>k</i>gate dielectrics

Microstructure and Electrical Properties of Al2O3–ZrO2 Composite Films for Gate Dielectric Applications

The Thermal Stability And Electrical Properties Of Laero(3) Films As High-K Gate Dielectrics

Structure and dielectric properties of Zr-Al-O thin films prepared by pulsed laser deposition

Fabrication and Characterization of Zr-Rich Zr-Aluminate Films for High-Kappa Gate Dielectric Applications

Properties of high-k gate dielectric LaAlO3 thin films

Thermal Stability and Electrical Properties of Pulsed Laser Deposited Hf–aluminate Thin Films for High-K Gate Dielectric Applications

Fabrication and Properties of the Y-Doped Al2o3 High-K Gate Dielectric Films

Growth and Characterization of Al2o3 Gate Dielectric Films by Low-Pressure Metalorganic Chemical Vapor Deposition

Structure and Thermal Stability of (zr0.6al0.4)o1.8 Thin Film on Strained SiGe Layer

Comparative Study of Pulsed Laser Deposited HfO 2 and Hf–aluminate Films for High- K Gate Dielectric Applications

High-k erbium oxide film prepared by sol-gel method for low-voltage thin-film transistor

Characteristics of Sandwich-Structured Al2O3/HfO2/Al2O3 Gate Dielectric Films on Ultra-Thin Silicon-on-insulator Substrates

Interfacial Structure and Electrical Properties of LaAlO 3 Gate Dielectric Films on Si by Metalorganic Chemical Vapor Deposition

Microstructures and properties of Er-doped Al2O3 thin films synthesized by ion beam assisted deposition

Optical Constants of Er2O3-Al2O3 Films Studied by Spectroscopic Ellipsometry