Abstract:High-quality ZnO films were grown on Si(1 0 0) substrates with low-temperature (LT) ZnO buffer layers by an electron cyclotron resonance (ECR)-assisted molecular-beam epitaxy (MBE). In order to investigate the optimized buffer layer temperature, ZnO buffer layers of about 1.1 μm were grown at different growth temperatures of 350, 450 and 550 °C, followed by identical high-temperature (HT) ZnO films with the thickness of 0.7 μm at 550 °C. A ZnO buffer layer with a growth temperature of 450 °C (450 °C-buffer sample) was found to greatly enhance the crystalline quality of the top ZnO film compared to others. The root mean square (RMS) roughness (3.3 nm) of its surface is the smallest, compared to the 350 °C-buffer sample (6.7 nm), the 550 °C-buffer sample (7.4 nm), and the sample without a buffer layer (6.8 nm). X-ray diffraction (XRD), photoluminescence (PL) and Raman scattering measurements were carried out on these samples at room temperature (RT) in order to characterize the crystalline quality of ZnO films. The preferential c-axis orientations of (0 0 2) ZnO were observed in the XRD spectra. The full-width at half-maximum (FWHM) value of the 450 °C-buffer sample was the narrowest as 0.209°, which indicated that the ZnO film with a buffer layer grown at this temperature was better for the subsequent ZnO growth at elevated temperature of 550 °C. Consistent with these results, the 450 °C-buffer sample exhibits the highest intensity and the smallest FWHM (130 meV) of the ultraviolet (UV) emission at 375 nm in the PL spectrum. The ZnO characteristic peak at 438.6 cm−1 was found in Raman scattering spectra for all films with buffers, which is corresponding to the E2 mode.

Controlled Growth of Zn-polar ZnO Film on MgAl2O4 (1 1 1) Substrate Using MgO Buffer Layer

Controlled Growth of Zn-Polar ZnO Films on Al-Terminated Α-Al 2 O 3 (0001) Surface by Using Wurtzite MgO Buffer

Controlled Growth Of Zn-Polar Zno Films On Al-Terminated Alpha-Al2o3(0001) Surface By Using Wurtzite Mgo Buffer

Surface Modification of Mgal2o4 (111) for Growth of High-Quality Zno Epitaxial Films

Controlled Growth of Zn-Polar Zno Epitaxial Film by Nitridation of Sapphire Substrate

Controlled Growth of O-polar ZnO Epitaxial Film by Oxygen Radical Preconditioning of Sapphire Substrate

Preparation and Characterization of Mg-doped ZnO Thin Films by Sol–gel Method

Structural Characterization of Zn-polar ZnO Films Grown on Mg-modified C-Al2o3 (0001) Surface

Metastable rocksalt ZnO interfacial layer and its influence on polarity selection of Zn-polar ZnO films

Growth of ZnO thin films on LSAT(111) substrates by plasma-assisted radio-frequency molecular beam epitaxy

Non-polar A-Plane ZnO Films Grown on R-Al2o3 Substrates Using GaN Buffer Layers

MBE‐grown ZnO Film on Sapphire Substrate with Double Buffer Layers

ZnO growth on Si with low-temperature CdO and ZnO buffer layers by molecular-beam epitaxy

Growth of Non-Polar Zn1−x Mg X O Thin Films with Different Mg Contents on R-Plane Sapphire Substrates by Plasma-Assisted Molecular Beam Epitaxy

Two-Step Growth of MgO Films on Sapphire (0001) Substrates by Radio Frequency Plasma-Assisted Molecular Beam Epitaxy

Effect of the ZnO buffer layer thickness on AZO film properties

ZnO Growth on Si with Low-Temperature ZnO Buffer Layers by ECR-assisted MBE

Characterizations of Cubic ZnMgO Films Grown on Si(111) at Low Substrate Temperature

Microstructure and Electrical Properties of Al-doped ZnO Thin Films

Structural and Optical Characterizations of ZnO Films Grown by Reactive Electron Beam Evaporation

Polarity Control Of Zno Films Grown On Nitrided C-Sapphire By Molecular-Beam Epitaxy