Abstract:With their excellent mechanical, thermal, and optical properties, silicon nitride (SiNx) films are widely used as both supporting and insulating materials for MEMS structures. Practical applications of SiNx films rely on their film quality, which will affect the performance and stability of the related devices. In general, SiNx films are deposited by low pressure chemical vapor deposition (LPCVD) or high-frequency (13.56 MHz) plasma-enhanced chemical vapor deposition (HF-PECVD). However, up to now, less reports about the deposition of SiNx films by low-frequency plasma-enhanced chemical vapor deposition (LF-PECVD) have been made. This paper reports the preparation of SiNx thin films by PECVD with a low frequency (380 kHz). The process parameters were carefully optimized for the growth of SiNx films. And the thicknesses and refractive indices of SiNx films were characterized by spectroscopic ellipsometry with small mean square error (MSE<2.5) using Tauc-Lorentz fitting model. It was revealed that the thickness uniformity, deposition rate, and wet etching rate of the as-prepared SiNx films strongly depend on the key process parameters, including RF frequency, power, gas flow ratio, deposition temperature and pressure. Our results also indicated that the refractive index of SiNx film can be rationally tuned to be 1.874 ~ 2.145 by LF-PECVD. Moreover, the wet etching rate of SiNx film in a diluted HF solution can be controlled to be 7.4 to 65.9 nm/min, and the deposition rate ranges from 23.5 to 260.8 nm/min. We also experimentally confirmed that the SiNx thin films deposited with low frequency (380 kHz) exhibit better thickness uniformity, higher deposition rate and lower wet etching rate, compared with those deposited with high frequency (13.56 MHz). Particularly, 150-mm-diameter SiNx thin films with high thickness uniformity (thickness nonuniformity <1.0%) were successfully produced in this work. With their tunable physical properties, the LF-PECVD SiNx thin films exhibit great potential in microelectronics and optoelectronics applications. Moreover, the SiNx films prepared by LF-PECVD are compared with those produced by HF-PECVD and DF-PECVD.

Interface Properties of Silicon Nitride Thin Films As Gate Insulator Layer for P-Si Thin Film Transistor

Electronic Properties of the Ultrathin Silicon Nitride Films Fabricated with Ammonia Plasma Prenitridation

Effect of High Deposition Rate on Chemical Bonds and Properties of SiN Film

Deposition and Thermoelectric Properties of N-Doped SiC Thick Films

Suppression and Characterization of Interface States at Low-Pressure-chemical-vapor-deposited SiNx/III-nitride Heterostructures

Chemical control of physical properties in silicon nitride films

Deposition of SiOxNy films as gate insulator via r.f. reactive sputtering

The effect of N/Si ratio on the a-SiiH/SiNx interface of a-SirH/SiNx TFT

Optical and Electrical Properties of N-doped ZnO and Fabrication of Thin-Film Transistors

Impact of H-Related Chemical Bonds on Physical Properties of SiNx:H Films Deposited via Plasma-Enhanced Chemical Vapor Deposition

Interfacial Structures and Properties of SiN Layer in a-Si Thin Film Transistors

Effects of Nitrogen Impurities on the Microstructure and Electronic Properties of P-Doped Si Nanocrystals Emebedded in Silicon-Rich Sinx Films

High-quality Silicon Nitride Films Prepared by Low-Frequency Plasma-Enhanced Chemical Vapor Deposition

Effect of reactive gases (NH3/N2) on silicon–nitride thin films deposited with diiodosilane (SiH2I2) precursors

A Comparative Study on Self-Aligned Top-Gate Thin-Film Transistors with Silicon Nitride as the Interlayer

Optimization of nitrided gate dielectrics by plasma-assisted and rapid thermal processing

Processing and Characterisation of PECVD Silicon Nitride Films

Thin films of silicon nitride deposited at room temperature by non-reactive magnetron sputtering: radiofrequency power and deposition time influence on the formation of α-Si3N4 and its optical properties

Interface Property of Silicon Nitride Films Grown by Inductively Coupled Plasma Chemical Vapor Deposition and Plasma Enhanced Chemical Vapor Deposition on In0.82al0.18as

Room-temperature deposition of low H-content SiNx/SiNxOy thin films using a specially designed PECVD system

The Effect of Si Surface Nitridation on the Interfacial Structure and Electrical Properties of (la2o3)0.5(sio2)0.5 High-K Gate Dielectric Films