Abstract:The group-Ⅲ nitrides and their related ternary alloys have been becoming the most attractive material for light emitting diodes (LEDs) and laser diodes (LDs) in the UV and blue spectral range. However, the origins of the yellow luminescence (YL), which is commonly observed in almost undoped and n-type GaN, remain unclear. The nature and the role of initial nitridation of sapphire surface and the generation of threading dislocation (TD) are ambiguous too. It is a possible way to resolve the above problems by studying the microstructures and optical properties combining the growth conditions. In this work, two kinds of GaN films were grown by MOCVD under different initial nitridation time (180 seconds for Sample A, and 90s for Sample B). The growth temperature is about 950℃. The cross-sectional transmission electron microscope (TEM) is performed near the GaN/sapphire interface. Corresponding the growth processes, there are three zones in the GaN layer: buffer layer, zone and sound zone. There are haystack-like domains in the faulted zone, in which there are high density of extended defects. The thickness of the faulted zone is about 0.4μm. Just above this region, the defects density is reduced sharply, and the quality of the layer is improved, which is identified by electron diffraction (ED) patterns. In comparison, Sample A shows about an order lower density of extended defects than Sample B, their columnar diameter is larger and its ED pattern is sharper, too. The buffer layer of Sample B is more smooth than Sample A. The appropriate rougher morphology of the buffer layer may cause that the structural disorder between the high-temperature (HT) grown island and the buffer layer is accommodated by Frank and Shockley partial dislocations. However, the TD is likely to propagate into the HT GaN from the smooth surface of the buffer layer grown after extensively nitridation of substrate. According to the position and width of X-ray diffraction peaks of (0002) and (0004), the size of crystalline grain, D and the residual strain could be calculated. The values of(D,e in)of Sample A and B are (175nm,0.167%) and (90nm,0.141%), respectively. Small size of crystalline grain may be advantageous to relieve the lattice and thermal mismatch stress, but it lead to higher density of extended defects. The width of GaN (0002) reflections of Sample A is 4min lower than that of Sample B. This result may be due to the lower screw TD. The higher density of screw TD may widen the GaN (0002) peak in X-ray rocking curve. In room temperature PL spectra, the ratio of band-edge emission intensity to YL one of Sample A is 3 orders larger than that of Sample B. Furthermore the YL in Sample B is stronger and has fine structure, while that in Sample A is nearly invisible in the PL spectrum. The GaN epilayer with high quality exhibits almost no YL emission. It is well known that the YL corresponds to the deformed crystal structure. We assigned that the screw TD and mixed TD are attributed to the YL referring to our XRD results.

Electrical properties of GaN deposited on nitridated sapphire by molecular beam epitaxy using NH3 cracked on the growing surface

Characterization of Crystal Lattice Constant and Dislocation Density of Crack-Free GaN Films Grown on Si(1 1 1)

Properties of GaN film grown by hydride vapor phase epitaxy

Defects in GaN Films Studied by Positron Annihilation Spectroscopy

Hydrogen induced changes on hydride vapor phase epitaxy of GaN growth

Molecular-beam-epitaxy Growth of GaN on GaAs(100) by Using Reactive Nitrogen Source

X-ray Diffraction, Photoluminescence and Secondary Ion Mass Spectroscopy Study of GaN Films Grown on Si(111) Substrate by Vacuum Reactive Evaporation

Molecular-beam-epitaxy growth of GaN on GaAs ( lOO ) by using reactive nitrogen source 2

Study of the Defects in GaN Epitaxial Films Grown on Sapphire by HVPE

Modulation Effects of Hydrogen on Structure and Photoluminescence of GaN Nanowires Prepared by Plasma-Enhanced Chemical Vapor Deposition

Heteroepitaxy of GaN by using an ionized N source

Research on Evolution of Relevant Defects in Heavily Mg-Doped GaN by H Ion Implantation Followed by Thermal Annealing

Structural and Stress Properties of AlGaN Epilayers Grown on AlN-Nanopatterned Sapphire Templates by Hydride Vapor Phase Epitaxy

The impact of initial growth and substrate nitridation on thick GaN growth on sapphire by hydride vapor phase epitaxy

Microstructural and Optical Properties of GaN Films on Nitrided Sapphire Substrates

Hydride Vapor Phase Epitaxy of GaN on Silicon Covered by Nanostructures

Microstructures of GaN films grown by low pressure metal-organic vapor phase epitaxy on (0 1 1 2) sapphire substrates

Homo-epitaxial Growth of High Crystal Quality GaN Thin Films by Plasma Assisted–molecular Beam Epitaxy

Structural Properties of GaN(0001) Epitaxial Layers Revealed by High Resolution X-ray Diffraction

Hydride vapor phase epitaxy growth of GaN on sapphire with ZnO buffer layers

Hydrogen induced quality improvement of GaNAs layers grown by chemical beam epitaxy