Abstract:High-performance submicron ZrSiO4 powder is prepared by a sol-gel-microemulsion-hydrothermal method (S-G-M-H). In this method, the transformation from sol to gel is constrained in the droplets of the microemulsion and accelerated by the hydrothermal process. The interface change of sol/oil to gel/oil makes the emulsion automatic demulsificate without demulsiflers, which means that the organic solvents can be recycled. The preparation process is low-cost and environmentally friendly. The results show that the synthesized ZrSiO4 powder owns the optimized median diameter (D50) of 0.67 mu m under the optimized preparation condition of hydrothermal treatment at 150 degrees C for 7 h. The ZrSiO4 particles are the agglomeration of the primary particles with a size of about 100 nm. As an opacifler, 15 wt% submicron ZrSiO4 powder added give a whiteness value of 85 to the opaque glaze, which is significantly better than commercial ZrSiO4 powder with the same amount added. Meanwhile, the obtained submicron powder has excellent sintering activity. After sintered at 1300 degrees C for 2 h, the ZrSiO4 pellets has the density of 4.32 g cm(-3) and the porosity of 0.31%. (C) 2020 Elsevier B.V. All rights reserved.

Synthesis of CdSiO3 powder by sol–gel method

Synthesis, Characterization and Application of Submicron ZrSiO4 Powder Via Sol-Gel-microemulsion-hydrothermal Method

Sol–gel Synthesis and Sintering of Nano-Size Li2TiO3 Powder

The Characterization and Preparation of Nano-Scale Fe Doping Tio2 by Sol-Gel Method (I) - the Crystallization and Thermal Decomposition Process of Fe Doping Tio2 Xerogel Powders Using Thermal Tg-Ir Spectrometry

Sol–gel preparation of Ge nanocrystals embedded in SiO2 glasses

Synthesis and Microwave Dielectric Properties of CaSiO3 Nanopowder by the Sol–gel Process

Preparation and Phase Formation Mechanism of CaSiO3 Doped with Mg/CaSiO3 by Sol-Gel Method

Synthesis and microwave dielectric properties of (Ca0.7Mg0.3)SiO3 nanopowder prepared at low temperature

Studies of synthesizing the SiC nanometer powders by chemical vapor reaction

Synthesis and Characterization of CIGS Powder

Solvothermal Synthesis of Copper Indium Gallium Selenide Powder

Preparation of Zirconia Powders by Sol-gel Process

Synthesis and Microwave Dielectric Properties of CaO–MgO–SiO2 Submicron Powders Doped with Li2O–Bi2O3 by Sol–gel Method

Study on CdS/SiO2 Quantum-dot-glass Prepared by Sol-gel Method

In-Situ Control of CaO-MgO-SiO2 Nanoparticles Synthesized by the Sol-Gel Method

Synthesis of ZnTiO3 Ceramic Powders by Sol-Gel Method

Preparation and Properties of CaTiO_3:Zn Nanoparticles Based on Sol-Gel Method

Preparation and characterization of ZnO-B2O3-SO2 by sol-gel method

PREPARATION AND CHARACTERIZATION OF Bi_4Si_3O_(12) POWDERS BY CHEMICAL SOLUTION DECOMPOSITION TECHNIQUE

Synthesis and Characterization of Ca3Co4O9 Nanoparticles by Citrate Sol-Gel Method

Preparation of Rare Earth/Alkaline Earth Composite Silicates Nanopowder by Water-Based Sol-Gel Method